Abstract:Supercritical CO2 can be used as a heat transfer fluid in a solar receiver, especially for a concentrating solar thermal power tower system. Such applications require better understanding of the heat transfer characteristics of supercritical CO2 in the solar receiver tube in a high temperature region. However, most of the existing experimental and numerical studies of the heat transfer characteristics of supercritical CO2 in tubes near the critical temperature region, and the corresponding heat transfer characteristics in the high temperature region are conducted. In this paper, a three-dimensional steady-state numerical simulation with the standard k-ε turbulent model is established by using ANSYS FLUENT for the flow and heat transfer of supercritical CO2 in a heated circular tube with an inner diameter of 6 mm and a length of 500 mm in the high temperature region. The effects of the fluid temperature (823–1023 K), the flow direction (horizontal, downward and upward), the pressure (7.5–9 MPa), the mass flux (200–500 kg·m–2·s–1) and the heat flux (100–800 kW·m–2) on the convection heat transfer coefficient and Nusselt number are discussed. The results show that the convection heat transfer coefficient increases while Nusselt number decreases nearly linearly with fluid temperature increasing. Both fluid direction and pressure have negligible effects on the convection heat transfer coefficient and Nusselt number. Moreover, the convective heat transfer coefficient and Nusselt number are enhanced greatly with the increasing of mass flux and the decreasing of heat flux, which is more obvious at a higher heat flux. The influences of buoyancy and flow acceleration on the heat transfer characteristics are also investigated. The buoyancy effect can be ignored within the present parameter range. However, the flow acceleration induced by the high heat flux significantly deteriorates the heat transfer preformation. Moreover, eight heat transfer correlations of supercritical fluid in tubes are evaluated and compared with the present numerical data. The comparison indicates that the correlations based on the thermal property modification show better performance in the heat transfer prediction in the high temperature region than those based on the dimensionless number modification. And Nusselt number predicted by the best correlation has a mean absolute relative deviation of 8.1% compared with the present numerical results, with all predicted data points located in the deviation bandwidth of ±20%. The present work can provide a theoretical guidance for the optimal design and safe operation of concentrating solar receivers where supercritical CO2 is used as a heat transfer fluid.

Experiments on Natural Convective Solar Thermal Achieved by Supercritical CO2/Dimethyl Ether Mixture Fluid

Experimental study on solar thermal conversion based on supercritical natural convection

A Preliminary Experimental Investigation on Characteristics of Natural Convection Based on Solar Thermal Collection Using Supercritical Carbon Dioxide

Experimental analysis on a novel solar collector system achieved by supercritical CO2 natural convection

Preliminary Study on A Solar Water Heater Using Supercritical Carbon Dioxide As Working Fluid

S056011 Study on a Natural Circulation Solar Water Heater Using Supercritical CO_2 As Working Fluid

Experimental investigation of CO2 thermosyphon flow and heat transfer in the supercritical region

Study of the Natural Circulation Flow Boiling Heat Transfer Based On Partially Superhydrophilic Surface Modification

Experimental Performance Analysis of Supercritical CO2 Thermodynamic Cycle Powered by Solar Energy

Investigation of Convection-Based Energy Systems Using Supercritical Carbon Dioxide As A Working Fluid

Experimental study of heat transfer characteristics of supercritical CO2 fluid in collectors of solar Rankine cycle system

Natural Convection Supercritical Fluid Systems for Geothermal, Heat Transfer, and Energy Conversion

An Experimental Investigation on Characteristics of Supercritical Co2-Based Solar Rankine System

Study of Solar Energy Powered Transcritical Cycle Using Supercritical Carbon Dioxide

Theoretical Investigations on Heat Transfer to H2O/CO2 Mixtures in Supercritical Region

A Numerical Study on Heat Transfer Characteristics of CO2-DME Mixture Fluid

Thermal and Hydrodynamic Characteristics of Supercritical Co2 Natural Circulation in Closed Loops

Forced Convection Heat Transfer of Supercritical CO2 in a Horizontal Circular Tube

Experimental study on the performance of solar Rankine system using supercritical CO2

Numerical Investigation on Heat Transfer of Supercritical CO2 in Solar Receiver Tube in High Temperature Region

Anomalous Enhancement of Heat Transfer to H2O/CO2 Mixtures in Near-Critical Region