Abstract:Supercritical CO2 can be used as a heat transfer fluid in a solar receiver, especially for a concentrating solar thermal power tower system. Such applications require better understanding of the heat transfer characteristics of supercritical CO2 in the solar receiver tube in a high temperature region. However, most of the existing experimental and numerical studies of the heat transfer characteristics of supercritical CO2 in tubes near the critical temperature region, and the corresponding heat transfer characteristics in the high temperature region are conducted. In this paper, a three-dimensional steady-state numerical simulation with the standard k-ε turbulent model is established by using ANSYS FLUENT for the flow and heat transfer of supercritical CO2 in a heated circular tube with an inner diameter of 6 mm and a length of 500 mm in the high temperature region. The effects of the fluid temperature (823–1023 K), the flow direction (horizontal, downward and upward), the pressure (7.5–9 MPa), the mass flux (200–500 kg·m–2·s–1) and the heat flux (100–800 kW·m–2) on the convection heat transfer coefficient and Nusselt number are discussed. The results show that the convection heat transfer coefficient increases while Nusselt number decreases nearly linearly with fluid temperature increasing. Both fluid direction and pressure have negligible effects on the convection heat transfer coefficient and Nusselt number. Moreover, the convective heat transfer coefficient and Nusselt number are enhanced greatly with the increasing of mass flux and the decreasing of heat flux, which is more obvious at a higher heat flux. The influences of buoyancy and flow acceleration on the heat transfer characteristics are also investigated. The buoyancy effect can be ignored within the present parameter range. However, the flow acceleration induced by the high heat flux significantly deteriorates the heat transfer preformation. Moreover, eight heat transfer correlations of supercritical fluid in tubes are evaluated and compared with the present numerical data. The comparison indicates that the correlations based on the thermal property modification show better performance in the heat transfer prediction in the high temperature region than those based on the dimensionless number modification. And Nusselt number predicted by the best correlation has a mean absolute relative deviation of 8.1% compared with the present numerical results, with all predicted data points located in the deviation bandwidth of ±20%. The present work can provide a theoretical guidance for the optimal design and safe operation of concentrating solar receivers where supercritical CO2 is used as a heat transfer fluid.

Experimental study of heat transfer characteristics of supercritical CO2 fluid in collectors of solar Rankine cycle system

An Experimental Investigation on Characteristics of Supercritical Co2-Based Solar Rankine System

Reference temperature correction and dimensionless number analysis for heat transfer of supercritical CO2 in horizontal tubes

S056011 Study on a Natural Circulation Solar Water Heater Using Supercritical CO_2 As Working Fluid

Experimental study on the performance of solar Rankine system using supercritical CO2

Numerical Investigation on Heat Transfer of Supercritical CO2 in Solar Receiver Tube in High Temperature Region

Experimental Performance Analysis of Supercritical CO2 Thermodynamic Cycle Powered by Solar Energy

1845 Study on Characteristics of Solar CO_2 Rankine System Using Super Critical CO_2

Effect study of super-critical CO<sub>2</sub> parameters on heat transfer performance of U-shaped double-pipe heat exchanger

Preliminary Study on A Solar Water Heater Using Supercritical Carbon Dioxide As Working Fluid

Effect study of super-critical CO2 parameters on heat transfer performance of U-shaped double-pipe heat exchanger

Study of Forced Convection Heat Transfer of Supercritical Co2 in A Horizontal Channel by Lattice Boltzmann Method

Forced Convection Heat Transfer of Supercritical CO2 in a Horizontal Circular Tube

Experimental study on solar thermal conversion based on supercritical natural convection

A Preliminary Experimental Investigation on Characteristics of Natural Convection Based on Solar Thermal Collection Using Supercritical Carbon Dioxide

Flow and Heat Transfer Characteristics of Supercritical CO2 in a Natural Circulation Loop

Experimental investigation on convection heat transfer of supercritical CO2 in porous media

Experimental and Simulation Investigation on Heat Transfer Characteristics of In-Tube Supercritical CO2 Cooling Flow

Study on the convective heat transfer characteristics of supercritical CO 2 in mini-channels under unilateral heating conditions for application in a compact solar receiver

Experimental investigation of CO2 thermosyphon flow and heat transfer in the supercritical region

Experiments and Heat Transfer Correlation Validations of Low-Parameter Region of sCO2 Flow in a Long Thin Vertical Loop