Abstract:To reduce the cost of silica-based materials, an agricultural waste, rice husk (RH), was transformed into higher valuable products such as MCM-41 and organo-functionalized MCM-41 in the frame of circular economy. RH is the biomass waste containing the highest amount of silica (214 g kg−1). Direct calcination of RH led to silica with low surface area (10 m2 g−1), which could not be transformed into MCM-41. After optimization, silica of 310 m2 g−1 was produced by washing RH with HCl 0.1 mol L−1 at 25 °C and calcination at 600 °C. Such silica was successfully transformed in one-step synthesis at 115 °C for 24 h into highly ordered MCM-41 (800 m2 g−1) and organo-functionalized MCM-41 (510 – 720 m2 g−1) including aminopropyl and amide derivatives of amino acids (Leucine, Serine and Tyrosine). The corresponding organo-triethoxysilanes alone or in mixture were directly added in the synthesis with silica from RH, octadecyltrimethylammonium and NaOH solution. Surfactant removal was successfully performed with EtOH/NH4NO3 solution at 60 °C. The mesopore diameter of the materials were homogeneous and varied from 3.8 to 4.2 nm depending on the organic functions. Thanks to the use of the concept of pseudomorphic transformation, the particle size of the materials ranged from 1 to 100 m. As proof of concept, the 50-100 m fraction (30% of the volume) was successfully used to fill columns to run size exclusion chromatography for protein separation. The largest protein, Bovine Serum Albumine (BSA) was excluded from all materials as its kinetic diameter (d = 7.2 nm) was larger than the mesopore diameter. The smallest proteins: carbonic anhydrase (d = 4.2 nm), myoglobin (d = 3.8 nm) and lysozyme (d = 3.4 nm) were retained by the materials. Their retention factor increased as the kinetic diameter decreased, as the mesopore diameter decreased and as the hydrophobicity of the materials increased. The best separation of proteins was obtained with MCM-41 functionalized with both Leucine and Serine amide derivatives.

Avoiding Carbothermal Reduction: Distillation of Alkoxysilanes from Biogenic, Green, and Sustainable Sources.

Siloxane-Mediated Ethylene Oligomerization with Iron-Based Catalysts: Retarding the Polymer Formation

Development of Comprehensive Utilization by Redistribution and Convertion of Methyltrichlorosilane

Highly Regioselective Sequential 1,1-Dihydrosilylation of Terminal Aliphatic Alkynes with Primary Silanes: Highly Regioselective Sequential 1,1-Dihydrosilylation of Terminal Aliphatic Alkynes with Primary Silanes†

Highly Regioselective Sequential 1,1‐Dihydrosilylation of Terminal Aliphatic Alkynes with Primary Silanes

Facile Synthesis of Silanols via Cesium Carbonate Catalyzed Hydrosilanes with Water

Spirocyclic Alkoxysilane Synthesized from Rice Straw Ash for Preparation of Eco-Friendly Hydrophobic Silicone Coatings

Oligomerization of glycerol on layered sodium silicate catalysts

Trialkoxysilane Grafting in Alcohols: A Simple Approach towards Modified Silica-Based Materials

On the Biocatalytic Synthesis of Silicone Polymers

Biocatalytic Synthesis Of (-)-1-Trimethylsilylethanol By Asymmetric Reduction Of Acetyltrimethylsilane With A New Isolate Rhodotorula Sp As2.2241

Integrated biorefinery incorporating the one-pot production of esters, monophenols, and alkoxysilanes

Direct pseudomorphic transformation of silica from rice husk into organo-functionalized MCM-41

Catalytic Disproportionation of Trimethoxysilane to Monosilane: Studies on Catalyst, Kinetics and Reactor Modeling

From silicon to silicones without dimethyldichlorosilane. Direct green mechanochemical synthesis of methylmethoxysilanes from silicon and dimethyl ether.

[M]-/Organo-Catalyzed Aerobic Functionalization of Alkylaryl-Siloxanes: Synthesis Carboxy-, Carbonyl- and Hydroxy-Aryl-Siloxanes

29Si NMR and UV−Raman Investigation of Initial Oligomerization Reaction Pathways in Acid-Catalyzed Silica Sol−Gel Chemistry

Naturally derived and synthetic polymers as biomimetic enhancers of silicic acid solubility in (bio)silicification processes

Silylium-Ion-Initiated Twofold Halodealkylation of Fully Alkylated Silanes

Impact of the Water Removal Method on Tetraethyl Orthosilicate Direct Synthesis: Experiment and Process Assessment