Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Numerical Experiments on Evaporation and Explosive Boiling of Ultra-Thin Liquid Argon Film on Aluminum Nanostructure Substrate.

Effects of Heat Source Temperature, Nanostructure, and Wettability on Explosive Boiling of Ultra-Thin Liquid Argon Film over Graphene Substrate: A Molecular Dynamics Study

Influence of Interface Wettability on Explosive Boiling of Ultra-Thin Liquid Films on a Heated Substrate Using Molecular Dynamics Simulations.

Molecular Dynamics Study on Explosive Boiling of Ultra-Thin Liquid over Solid Substrate: Considering Interface Wettability of Argon/MoS2

Investigation of the Effects of Surface Wettability and Surface Roughness on Nanoscale Boiling Process Using Molecular Dynamics Simulation

Molecular Dynamics Simulation of the Evaporation of Thin Liquid Sodium Film on the Conical Nanostructure Surface

Molecular Dynamics Simulation on Explosive Boiling of Liquid Argon Film on Copper Nanochannels

Study of Pool Boiling Heat Transfer on Concave Nanostructured Surface With Molecular Dynamics Simulation

Numerical simulation of single aluminum droplet evaporation based on VOF method

Molecular Dynamics Simulation of Explosive Boiling on Concave Nanostructured Surface

A Molecular Dynamics Investigation on Evaporation of Thin Liquid Films

Droplet Evaporation to Boiling in Van Der Waals Fluid

Molecular dynamics investigation of the effect of nanostructured surfaces on flow boiling

Molecular Dynamics Simulation on Bubble Nucleation and Boiling Heat Transfer of R1336mzz(Z) Nanofilm with Varying Boundary Heating Rates

Molecular Dynamics Investigation on Regular Patterns of Nano-Droplet Evaporation

Wetting and Evaporation of Argon Nanodroplets on Smooth and Rough Substrates: Molecular Dynamics Simulations

Molecular Dynamics Simulation of Heat Transport Through Solid-Liquid Interface During Argon Droplet Evaporation on Heated Substrates.

Probing the Transient Evolution and Heat Transfer of Nascent Liquid Film During Initial Condensation

Molecular Dynamics Simulation of Characteristics of the Nanodroplet Evaporation

Molecular Dynamics Simulation on Rapid Boiling of Thin Water Films on Cone-Shaped Nanostructure Surfaces

Molecular dynamic simulation of platinum heater and associated nano-scale liquid argon film evaporation and colloidal adsorption characteristics