Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Molecular Dynamics Investigation on Regular Patterns of Nano-Droplet Evaporation

ICOPE-15-C064 Numerical Analysis of a Single Water Droplet Evaporation Caused by Laser Radiation

Molecular dynamics simulations of the evaporation of particle-laden droplets

Evaporation Kinetics of Nano Water Droplets using Coarse-Grained Molecular Dynamic Simulations

Molecular Dynamics Study of Binary Nanodroplet Evaporation on a Heated Homogeneous Substrate

Molecular Dynamics Simulation on Interface Characteristics of Micro Droplets

Molecular Dynamics Simulation on Evaporation of a Suspending Difluoromethane Nanodroplet

Droplet Evaporation to Boiling in Van Der Waals Fluid

Suspended water nanodroplets evaporation and its deviation from continuum estimations

A molecular study on the liquid-vapor interphase transport

Molecular Dynamics Simulations on Evaporation of a Suspended Binary Mixture Nanodroplet

Droplet-particle collision dynamics: A molecular dynamics simulation

The Interaction Between Droplet Evaporation and Turbulence with Interface-Resolved Direct Numerical Simulation

Effects of Free Surface Evaporation on Water Nanodroplet Wetting Kinetics: A Molecular Dynamics Study

A Molecular Dynamics Investigation on Evaporation of Thin Liquid Films

Molecular Dynamics Study On Interface Properties And Interphase Transport

Pattern formation during the evaporation of a colloidal nanoliter drop: a numerical and experimental study

Molecular dynamics study of evaporation induced by locally heated argon liquid

Kinetic and Molecular Dynamics Simulations of N-Dodecane Droplet Heating and Evaporation

Effects of Free Surface Evaporation on Water Nano-Droplet Wetting Kinetics: A Molecular Dynamics Study

Effect of Wall Adsorption on the Nano-Droplet Evaporation in a Nano-Channel: A Molecular Dynamics Investigation