Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

Embedded SiGe Source/drain and Temperature Degrading Junction Performance on <110> 45 Nm MOSFETs

Deterioration of junction performance with temperature effect for 45 nm Si-capping MOSFETs on <110> silicon substrate

Strain Optimization in Silicon P-Type Double-Gate MOSFET at 7nm Channel Length

Performance Comparison Between Si and Ge pDG-FETs for Different Channel Lengths Based on Hole Transport Simulation

Quantum Transport Study of Si Ultrathin-Body Double-Gate Pmosfets: ${I}$ – ${V}$ , ${C}$ – ${V}$ , Energy Delay, and Parasitic Effects

Strained Pmosfets With Sige Channel And Embedded Sige Source/Drain Stressor Under Heating And Hot-Carrier Stresses

Nige Metal Source/Drain Ge Pmosfets For Future High Performance Vlsi Circuits Applications

Performance of Surface Carrier Mobility for Nano-Node Strained (110) MOSFETs with Temperature Effect

MOSFET Performance Manufactured on &lt;100&gt; Silicon Wafer Using CESL Strain Technology with Temperature Effect

Nano-scale Si-capping Thicknesses Impacting Junction Performance on <110> Silicon Substrate

Ge CMOS Technology with Advanced Interface and Junction Engineering.

III-V/Ge MOS Device Technologies for Low Power Integrated Systems

Study of Drain-Extended Nmos under Electrostatic Discharge Stress in 28 Nm and 40 Nm Cmos Process

The Influence of Silicide Technique on the Device Performance for Deep Sub-Micro Pmosfets

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Si-capping thicknesses impacting compressive strained MOSFETs with temperature effect

The improvement of MOSFET electric characteristics through strain engineering by refilled SiGe as Source and Drain

Body Effect of SiGe and CESL Strained Nano-Node NMOSFETs on (100) Silicon Substrate

The Enhancement of MOSFET Electric Performance Through Strain Engineering by Refilled Sige As Source and Drain

Study of temperature effects of mobility, swing, and early voltages on strained MOSFET devices

Fabrication and Optimization of a High Speed Deep-Trench Super-Junction MOSFET with Improved EMI Performance