Abstract:Gas explosion in connected vessels usually leads to high pressure and high rate of pressure increase which the vessels and pipes can not tolerate. Severe human casualties and property losses may occur due to the variation characteristics of gas explosion pressure in connected vessels. To determine gas explosion strength, an experimental testing system for methane and air mixture explosion in a single vessel, in a single vessel connected a pipe and in connected vessels has been set up. The experiment apparatus consisted of two spherical vessels of 350 mm and 600 mm in diameter, three connecting pipes of 89 mm in diameter and 6 m in length. First, the results of gas explosion pressure in a single vessel and connected vessels were compared and analyzed. And then the development of gas explosion, its changing characteristics and relevant influencing factors were analyzed. When gas explosion occurs in a single vessel, the maximum explosion pressure and pressure growth rate with ignition at the center of a spherical vessel are higher than those with ignition on the inner-wall of the vessel. In conclusion, besides ignition source on the inner wall, the ignition source at the center of the vessels must be avoided to reduce the damage level. When the gas mixture is ignited in the large vessel, the maximum explosion pressure and explosion pressure rising rate in the small vessel raise. And the maximum explosion pressure and pressure rising rate in connected vessels are higher than those in the single containment vessel. So whenever possible, some isolation techniques, such as fast-acting valves, rotary valves, etc., might be applied to reduce explosion strength in the integrated system. However, when the gas mixture is ignited in the small vessel, the maximum explosion pressures in the large vessel and in the small vessel both decrease. Moreover, the explosion pressure is lower than that in the single vessel. When gas explosion happens in a single vessel connected to a pipe, the maximum explosion pressure occurs at the end of the pipe if the gas mixture is ignited in the spherical vessel. Therefore, installing a pipe into the system can reduce the maximum explosion pressure, but it also causes the explosion pressure growth rate to increase. (C) 2013 Elsevier Ltd. All rights reserved.

Study on the Development of the Medium-Scale Gas Explosion Integrated Testing System

A study on integrated system of tracer gas leakage detection in detonation experiment

Test system for the visualization of dynamic disasters and its application to coal and gas outburst

Explosion and vented explosion behaviors of low-concentration gas in large-scale pipes

Different Gas Explosion Mechanisms And Explosion Suppression Techniques

Study on the evolution characteristics of coal spontaneous combustion and gas coupling disaster region in goaf

Experimental Study on the Isolation Effect of an Active Flame-Proof Device on a Gas Explosion in an Underground Coal Mine

Special Explosion Experiments of Testing "the Method of Preventing Gas Explosions in Coal Mines" in the Lane

Study on electric potential response's spatial distribution characteristics to damaging localization evolution of gas-bearing coal under load

A study on source identification of gas explosion in coal mines based on gas concentration

Study on the formation characteristics of coal dust cloud and dynamic behavior of flame during explosion in a Hartmann tube

Experimental study to assess the explosion hazard of CH4/coal dust mixtures induced by high-temperature source surface

Experimental investigation on the gas pressure influence laws and mechanical mechanism of coal and gas outbursts

Analysis of the Interaction Mechanism of the Risk Factors of Gas Explosions in Chinese Underground Coal Mines

Study on gas transport characteristics of positive pressure beam tube system and its application to coal spontaneous combustion early warning

Study on Gas Explosion Propagation Law and Explosion Venting in an Excavation Roadway

Study on Gas Explosion Characteristics in Urban Utility Tunnels

Development of a Graded Early Warning Index System and Identification of Critical Temperatures for Coal Spontaneous Combustion Using Composite Gas Characteristics

Experimental Investigation of Gas Explosion Characteristic in Linked Vessels

Experimental Investigation of Gas Explosion in Single Vessel and Connected Vessels

Experiments Testing "the Method of Preventing Gas Explosions in Coal Mines" in the Experimental Lane