Abstract:To shorten the testing cycle of volatile organic compounds (VOCs) released from the wood-based panels,reduce testing costs and improve the level of environmental protection of products,we designed a new DL-SW microcabin.It was put forward for detecting the emissions of VOCs from medium density fiberboard,plywood and particleboard under the pre-setting test conditions.The components and the mass of the VOCs were confirmed by the gas chromatography-mass spectrometry (GC-MS).The data of the DL-SW micro-cabin was compared with that of the lm3 chamber method to analysis the correlation of the two methods and verify the feasibility of the new DL-SW microcabin.Results showed that total volatile organic compounds (TVOC) of the three kinds of panels had the fastest decrease during the period of lth-3rd days,and eventually reached equilibrium state within 14 days.The main components of VOCs were aromatic hydrocarbons,alkenes and alkanes,accounting for more than 50％ of the total amount of TVOC,followed by aldehydes,alcohols,esters and ketones.The VOCs emissions increased significantly under the high temperature and high humidity.The initial emission concentrations of medium density fibreboard,plywood,particleboard were 970.56,3 954.49 and 7 658.00 μg/m3,respectively.The release trends of the TVOC and the kinds of VOCs detected by the two methods were the same.The relative deviations of TVOC equilibrium concentrations were 13.95％,11.04％ and 9.06％,respectively.According to TVOC equilibrium concentrations of the two methods,the linear equation was y=0.877 5x+0.344 7 and the fitting degree was 0.996.The time for the detection of DL-SW micro-cabin was shorter than the half of the 1 m3 chamber method.The DL-SW micro-cabin has the advantages of low cost,high reliability,adjustable temperature,and humidity and air exchange rate to simulate various test environments and achieve the VOCs rapid detection of wood-based panels.It could be used as a comparison of the results obtained by the 1 m3 chamber to improve the level of environmental protection of the wood-based panels.

Study on Determination Method of the Volatile Organic Compounds Emissions from Particleboards for Indoor Finishing

Study on Reducing the Volatile Organic Compounds Emissions from Different Processing Particleboards

Volatile Organic Compounds Emissions of Particleboards in Response to Processing Parameters

Effect of the Surface Finishing Methods on Particleboard Volatile Organic Compounds and Formaldehyde Emission

Determination of Volatile Organic Compound Emission from Wood-based Panels

Identification and characterization of odorous volatile organic compounds emitted from wood-based panels

Optimization of Headspace Solid-phase Microextraction of VOCs in Eucalyptus Particleboard

Study on Determination and Composition of Volatile Organic Compounds of Larix Gmelini Particles

Influence of Processing Parameters on VOC Emission from Particleboards.

Headspace Solid-phase Microextraction for the Determination of Volatile Organic Compounds in Larix Gmelini Particles

Characteristic of Volatile Organic Compounds (vocs) Released from Coating Particle Boards Using Small Chamber Method

Effect of Temperature, Relative Humidity and ACH on the Emission of Volatile Organic Compounds from Particleboard

Study on the total volatile organic compounds (TVOC) release from finishing particleboards

Notice of Retraction Analysis the Source of Volatile Organic Compounds Emission from Particleboards

Volatile Organic Compound Emission from Medium Density Fiberboard Tested in a Small Environmental Chamber

Characterization of organic release kinetics in particleboard using a dual model fitting methodology

Effects of Volatile Organic Compounds Released by Different Decorative Particleboards on Indoor Air Quality

Characteristics of Volatile Organic Compounds Released from Various Types of Decorative Particleboards

Study on the Effect of Humidity on Formaldehyde Emission Parameters of Wood-Based Panels

Gas-diffusion microextraction combined with HPLC-DAD for the comprehensive analysis of volatile carbonyl compounds in wood-based panels

Design of DL-SW Micro-Cabin for Rapid Detection and Analysis of VOCs from Wood-Based Panels