Abstract:Supercritical cryogenic fluids are widely used in thermal equipment for liquid air energy storage (LAES), hypersonic aircraft, liquid hydrogen, etc. Unstable flow of supercritical fluids can cause thermal fatigue, mechanical vibration, noise, etc. In this work, a cryogenic heat transfer system was established to study the flow instability characteristics of supercritical nitrogen (SN2) in a vertical tube. The dynamic unstable flow of density-wave oscillation was captured in the experimental system. The oscillation amplitude of wall temperature is more than 100 K and the temperature peak can reach 150% of Tave. Based on the pseudo-two-phase model, the effect of several key parameters was analyzed. Unstable flow is prone to occur when the outlet state is located in the two-phase-like (TPL) region with dramatic changes in physical properties. The outlet state can be kept away from the TPL region by two approaches. One is to locate the outlet in the vapor-like (VL) region by increasing the heat flux, decreasing the mass flux, and increasing the inlet temperature; the other one is to locate the outlet in the liquid-like (LL) region by decreasing the heat flux, increasing the mass flux, and decreasing the inlet temperature. When Pin is close to Pc, the TPL region is extremely narrow, and the outlet state is easily located in the VL region. The dimensionless p-h diagram is proposed to divide the unstable flow region of supercritical fluids. Unstable flow occurs in the region where the outlet dimensionless enthalpy (NSPCO) is located between the VL boundary (NSPCO_V) and the LL boundary (NSPCO_L). The analysis of flow instability characteristics and the proposed prediction methods can provide a basis for the system design of supercritical cryogenic fluids.

Analysis of Ledinegg Flow Instability in Natural Circulation at Supercritical Pressure

Stability Analysis of a Supercritical Water Natural Circulation Loop

Study on the Stability of Natural Circulation Under Supercritical Pressure

Experimental Investigations on Flow Instabilities in a Forced Circulation Loop at Near-Critical and Supercritical Pressures

Experimental Study of Trans-Critical and Supercritical Co2 Natural Circulation Flow in A Closed Loop

Analysis of Flow Instability Types and Dynamic Behaviors for Supercritical Water

Effect of heat transfer on the instabilities and transitions of supercritical CO2 flow in a natural circulation loop

Experimental Investigations on Flow Characteristics of Two Parallel Channels in A Forced Circulation Loop with Supercritical Water

Modeling and Analysis of Supercritical Flow Instability in Parallel Channels

Experimental Study and Prediction of Flow Instability of Supercritical Nitrogen in a Vertical Upward Tube

Flow and Heat Transfer Instability of Supercritical Carbon Dioxide in a Vertical Heated Tube

Near-Critical Natural Circulation Flows Inside an Experimental Loop: Stability Map and Heat Transfer

Study on Static Characteristic in Natural Circulation Under Supercritical Pressure

Theoretical Study on the Flow Instability of Supercritical Water in the Parallel Channels

Thermal and Hydrodynamic Characteristics of Supercritical Co2 Natural Circulation in Closed Loops

Two-phase instability analysis in natural circulation loops of China Advanced Research Reactor

Numerical Investigations on Ledinegg Instability in Single and Parallel Channels under Localized Heat Source

Experimental Study on Two-Phase Natural Circulation Flow Instability under Low Pressure and Low Steam Quality

EXPERIMENTAL STUDY ON LOW PRESSURE FLOW INSTABILITY

Stability analysis of two-phase flow in a low quality natural circulation loop with a lumped parameter model

Flow Instability in Parallel-Channel Systems with Ultra-Supercritical Water