Investigation of forced convection heat transfer of supercritical pressure water in a vertically upward internally ribbed tube
Jianguo Wang,Huixiong Li,Bin Guo,Shuiqing Yu,Yuqian Zhang,Tingkuan Chen
DOI: https://doi.org/10.1016/j.nucengdes.2009.04.012
IF: 1.7
2009-01-01
Nuclear Engineering and Design
Abstract:In the present paper, the forced convection heat transfer characteristics of water in a vertically upward internally ribbed tube at supercritical pressures were investigated experimentally. The six-head internally ribbed tube is made of SA-213T12 steel with an outer diameter of 31.8mm and a wall thickness of 6mm and the mean inside diameter of the tube is measured to be 17.6mm. The experimental parameters were as follows. The pressure at the inlet of the test section varied from 25.0 to 29.0MPa, and the mass flux was from 800 to 1200kg/(m2s), and the inside wall heat flux ranged from 260 to 660kW/m2. According to experimental data, the effects of heat flux and pressure on heat transfer of supercritical pressure water in the vertically upward internally ribbed tube were analyzed, and the characteristics and mechanisms of heat transfer enhancement, and also that of heat transfer deterioration, were also discussed in the so-called large specific heat region. The drastic changes in thermophysical properties near the pseudocritical points, especially the sudden rise in the specific heat of water at supercritical pressures, may result in the occurrence of the heat transfer enhancement, while the covering of the heat transfer surface by fluids lighter and hotter than the bulk fluid makes the heat transfer deteriorated eventually and explains how this lighter fluid layer forms. It was found that the heat transfer characteristics of water at supercritical pressures were greatly different from the single-phase convection heat transfer at subcritical pressures. There are three heat transfer modes of water at supercritical pressures: (1) normal heat transfer, (2) deteriorated heat transfer with low HTC but high wall temperatures in comparison to the normal heat transfer, and (3) enhanced heat transfer with high HTC and low wall temperatures in comparison to the normal heat transfer. It was also found that the heat transfer deterioration at supercritical pressures was similar to the DNB at subcritical pressures.