Abstract:Three different supercritical fluids (SCF), CO2, dimethyl ether (DME), and propane, are investigated as potential solvents for processing two lactide-based terpolymers and two perfluorocyclobutyl (PFCB) aryl ether polymers. The repeat unit of the lactide-based terpolymers consists of a 1:1:1 ratio Of L-lactide, diglycidyl ether of bisphenol A (DGEBA), and, in one case, 4,4'-hexafluoroiso-propylidenediphenol (6F-Bis-A) and, in the other case, 4,4'-isopropylidenediphenol (6H-Bis-A). The PFCB-based polymers are synthesized from 1,1-bis[4-[(trifluorovinyl)oxy]phenyl]hexa fluoroisopropylidene (6FVE) and from bis(trifluorovinyloxy)biphenyl (BPVF). For both classes of polymer the steric effect of the hexafluoroisopropylidene (6F) group reduces chain-chain interactions, disrupts electronic resonance between adjacent aromatic groups, and improves solubility. The two lactide-based terpolymers do not dissolve in CO, or propane, but dissolve in DME. At room temperature the poly(lactide 6F-BisA DGEBA) terpolymer dissolves at 700 bar lower pressure in DME compared to the poly(lactide 6H-Bis-A DGEBA) terpolymer. Although the 6FVE polymer dissolves in all three SCF solvents, pressures in excess of 800 bar are needed to dissolve this polymer in CO, and propane while 6FVE dissolves in DME at pressure below 150 bar. The other PFCB-based polymer (BPVE) only dissolves in DME, again at low pressure, although BPVE drops out of solution as the system temperature is raised above similar to 40 degrees C, whereas 6FVE remains in solution in DME for temperatures up to 90 degrees C. (c) 2005 Wiley Periodicals, Inc.

Tetrafluoroethylene copolymers with sulfonyl fluoride pendants: Syntheses in supercritical carbon dioxide, polymerization behaviors, and properties

2,2‐Bistrifluoromethyl‐4,5‐difluoro‐1,3‐dioxole‐co‐tetrafluoroethylene Copolymers with Different Compositions: Synthesis, Chain and Condensed Matter Structures and Optical Properties

Free Volume Characteristics Of 2,2-Bistrifluoromethyl-4,5-Difluoro-1,3-Dioxole-Co-Tetrafluoroethylene Copolymers: Effect Of Composition And Molecular Weight

Efficient Synthesis of Novel Polyethylene Graft Copolymers Containing Polyfluorosiloxane Side Chains

Design of Well-Defined Polyethylene-g-poly-methyltrifluorosiloxane Graft Copolymers Via Direct Copolymerization of Ethylene with Polyfluorosiloxane Macromonomers

Synthesis and characterization of fluorine-containing polyester based on phthalic anhydride and tetrafluoropropyl glycidyl ether

Synthesis and Characterization of Trifluoromethyl Substituted Styrene Polymers and Copolymers with Methacrylates: Effects of Trifluoromethyl Substituent on Styrene

TFE Terpolymers: Once Promising - Are There Still Perspectives in the 21st Century: Synthesis, Characterization, and Properties-Part I

Synthesis of Poly(methyl (trifluoropropyl) Siloxane) and Its Crosslinking Characteristics

Synthesis and Solubility of Linear Poly(tetrafluoroethylene-co-vinyl Acetate) in Dense CO2: Experimental and Molecular Modeling Results

Supported ATRP of Fluorinated Methacrylates in Supercritical Carbon Dioxide: Preparation of Scco2 Soluble Polymers with Low Catalytic Residues

Synthesis and characterization of novel fluoropolymers containing sulfonyl and perfluorocyclobutyl units

Synthesis and Characterization of Perfluorocyclopentene‐thioether Polymers

Novel Non-Fluorinated Surfactants for Emulsion Polymerization of Fluorinated Monomers

Preparation and fluorine enrichment behavior of fluorinated polyester

Influence of sulfonyl fluoride monomers on the mechanism of emulsion copolymerization with the preparation of proton-conducting membrane precursors

Partially Bio-Based and Fluorinated Polysiloxane with High Transparency and Low Dielectric Constant

Studies on Oligomerization and Kinetic of Pyrolyzing Trifluoromethane to Tetrafluoroethylene and Hexafluoropropylene

Impact of hexafluoroisopropylidene on the solubility of aromatic-based polymers in supercritical fluids

Thermal and Optical Properties, and Aggregated Structure of Poly(substituted methylene)s Produced by Radical Polymerization of Fumarates Containing Fluorine-Substituted Alkyl Ester Groups

Fluorescence and stimuli-responsive performance of polymer composites filled with tetraphenylethene derivatives