Abstract:In this work, experiment was conducted to examine the thermo-physical properties of an alternative refrigerant to HCFC-22 in the presence of polyol ester (POE). The new alternative refrigerant is a mixture of HFC-32/125/161, whose physical properties are similar to HCFC-22 but has a lower global warming potential (GWP) than that of R407C. POE is used as the tested lubricating oil in the experiment. The saturated vapor pressure data and vapor–liquid equilibrium data of nine different mass fractions of the new refrigerant and polyol ester (POE) in the temperature range of 253–323K were measured by single-phase cycle method. The experiment results showed that there was no stratification, no sediment generation in the liquid phase of the mixture, and the color of liquid phase of the mixture had no change in the equilibrium cell before and after the experiment with the POE concentration greater than 20% and the temperature higher than 258K; with POE concentration lower than 20% and temperature lower than 258K, stratification began to appear. Meanwhile, when POE and the refrigerant were miscible, the saturated pressure data of the mixture (HFC-32/125/161+POE) revealed that POE had a very small impact on saturated vapor pressure of the mixture (almost negligible) when POE was less than 10% of the mixture; POE has an obvious effect on the saturated vapor pressure of the mixture when there is more than 10% POE in the mixture, especially when the temperature is higher than 283.15K. Experimental data were correlated by Flory–Huggins model, Heil model, NRTL model and Wilson model. The results showed that to the average and maximum pressure deviation, the results were better with considering the effects of temperature on the energy parameters. Among the above models, the NRTL activity coefficient model was the best, the Heil and Wilson models followed and the Flory–Huggins model had the largest deviation from the experimental data.

PR Equation of State Based Friction Theory Viscosity Model for Liquid Refrigerants

Investigation on the Vapor–Liquid Equilibrium for the Ternary Mixture HFC-32 + HFC-125 + HFC-161 at Temperatures from 265.15 K to 303.15 K

Comparison of Different State Equation on Friction Theory Viscosity Model of R134a

Viscosity modeling of several HFC refrigerants using the friction theory

Investigation on Liquid Density Data at the Bubble Point and Equations for the Refrigerant Hfc-404a over A Wide Temperature Range

Isothermal Vapor−Liquid Equilibrium of (Pentafluoroethane + Fluoroethane) at Temperatures between (265.15 and 303.15) K Obtained with a Recirculating Still

Vapor-liquid Equilibrium Measurements and Models for the Ternary Mixtures of R1234yf + R32 + R125 and R1234yf + R32 + CO2

Viscosity Correlation of CO2, HFCs, HFOs, and Their Mixtures: Review of Experimental Data and Modeling Techniques

Modified Vapor Pressure Model Based on Corresponding-States Principle for Pure and Mixed Refrigerants

Density and Viscosity Measurement of R513A and a Modified Residual Entropy Scaling Model for Predicting the Viscosity of HFC/HFO Refrigerants

Viscosity Prediction of Pure Refrigerants Applying the Residual Entropy Scaling Theory Coupled with a “generalized Chart” Parametrization Method for the Statistical Associating Fluid Theory

Liquid Viscosity Measurements for the Binary and Ternary Refrigerant Mixtures of R134a, R1234ze(E), and R1234yf

Phase Equilibria of Difluoromethane (R32), 1,1,1,2-Tetrafluoroethane (r134a), and Trans-1,3,3,3-tetrafluoro-1-propene (r1234ze(e)) Probed by Experimental Measurements and Monte Carlo Simulations

Modeling vapor-liquid equilibrium of refrigerants using an equation of state for square-well chain fluid with variable range

An experimental investigation and correlation of the viscosity refrigerant/oil solutions

Calculation model and analysis of thermodynamic properties of R32 refrigerant

Vapor-liquid Equilibrium Measurements for the Binary Mixtures of Pentafluoroethane (R125) with 2,3,3,3-Tetrafluoroprop-1-ene (r1234yf) and 3,3,3-Trifluoropropene (R1243zf)

Surface Tension and Liquid Viscosity of R32+R1234yf and R32+R1234ze

Experimental studies on a mixture of HFC-32/125/161 as an alternative refrigerant to HCFC-22 in the presence of polyol ester

New Measurements of Vapor Liquid Equilibria of Binary Mixtures of R 1234 ze ( E ) and R 1234 yf with R 134 a or R 125

Isothermal vapor–liquid equilibrium data for the binary mixture ethyl fluoride (HFC-161) + 1,1,1,2,3,3,3-heptafluoroproane (HFC-227ea) over a temperature range from 253.15 K to 313.15 K