Abstract:The heterogeneous chemistry coupling of H2 and CO over platinum was investigated experimentally and numerically for H2/CO/O2/N2 mixtures with overall lean equivalence ratios φ=0.13–0.26, H2:CO molar ratios 1:5–3:1, and a pressure of 5bar. Experiments were performed in an optically accessible channel-flow reactor at surface temperatures 510–827K and involved in situ Raman measurements of major gas-phase species concentrations and thermocouple measurements of surface temperatures. Emphasis was placed on the low temperature range 510–600K, whereby H2 inhibited the CO oxidation, and which was of particular relevance to gas turbine idling and part-load operation. Comparisons of measurements with 2-D simulations attested the aptness of the employed kinetic scheme, not only for H2/CO fuel mixtures but also for pure CO. Measured and predicted transition temperatures below which H2 inhibited CO oxidation agreed well with each other, showing a main dependence on the overall equivalence ratio (550±5K at φ=0.13 and 600±5K at φ=0.26) and a weaker dependence on the H2:CO ratio. Furthermore, this inhibition was non-monotonically dependent on the H2:CO ratio, becoming higher at a value of 1:1. The inhibiting kinetic effect of H2 was an outcome of the competition between H2 and CO/O2 for surface adsorption and, most importantly, of the competition between the adsorbed H(s) and CO(s) for surface-deficient O(s). Finally, transient simulations in practical catalytic channels revealed the interplay between kinetic and thermal effects. While at φ=0.13 the H2/CO reactive mixture exothermicity was insufficient to overtake the kinetic inhibition, at φ=0.26 catalytic ignition could still be achieved at temperatures well-below the transition temperature. The effect of H2:CO molar ratio on the light-off times was quite strong, suggesting care when designing syngas catalytic rectors with varying compositions.

Experimental Study on CO Oxidation Inhibited by Chlorine

Kinetic Study on High Temperature Oxidation of CO/H2/Cl2 Mixture

Kinetic modeling of CO oxidation in H_2/Cl_2/O_2/N_2 mixture

Effect of Oxygen Volume Fraction in Feed Stream on p-Xylene Oxidation Reactor

Experimental Investigation and Numerical Simulation of CO Oxidation with HCl Addition

Experimental Study on CCl 4 /CH 4 /O 2 /N 2 Oxidation

Influence of chlorine on methane oxidation

High Temperature Oxidation of Dichloromethane in Air

Effect of Residual Chlorine on the Catalytic Performance of Co3O4 for CO Oxidation

Understanding the Catalytic Oxidation of Hydrogen Chloride to Chlorine from Thermodynamics and Reaction Kinetics

Studies on ethylene oxychlorination III. Hot model test in a fluidized bed

Kinetic Analysis of Laminar Combustion Characteristics of a H 2 /Cl 2 Mixture at CO 2 /N 2 Dilution

Study of Metal Oxides in the Catalytic Oxidation of HCl to Cl2

Production Process of Chlorine from HCl by Catalytic Oxidation

Kinetic Interactions Between Hydrogen and Carbon Monoxide Oxidation over Platinum

An experimental and chemical kinetic modeling study of the role of potassium in the moist oxidation of CO

Comparative Investigation On Chlorobenzene Oxidation By Oxygen And Ozone Over A Mnox/Al(2)O(3 )Catalyst In The Presence Of So2

Chemical and Thermal Effects of Co2 on Extinction Limit and Flame Microstructure in Ch4/Air Counterflowdiffusion Flame with Various Pressures

Inhibition of CCl Formation During the Combustion of MSW Gasification Syngas: an Experimental Study on the Synergism and Competition Between Oxidation and Chlorination.

Effect mechanism of NO/SO2 on Cl/Cl2 formation in coal-fired flue gas

Study on Direct Conversion of Ch4-Co2 to Oxygenated Compounds by Two-Step Reaction Sequence