Abstract:The flow condensation heat transfer coefficient of R134a inside two helical micro-fin tubes with outer diameter of 6.35 mm and helical angles of 18o and 28o respectively were experimentally studied at a high mass flux ranging from 500 to 1100 kg m−2 s−1. The condensation temperatures are 35°C, 40°C and 45°C, and the vapor qualities ranges from 0.95 to 1.00 at the inlet section and from 0.00 to 0.05 at the outlet section. Experimental results show that there are annular and intermittent flow regimes inside the tube under experimental conditions, the ratio of annular flow region to the total heat transfer region is about 70%. The liquid film flow changes from rotational flow to coexistence of rotational and horizontal flows when the vapor quality is 0.475±0.08, 0.486±0.06 and 0.521±0.05, respectively and the corresponding saturation temperature is 35°C, 40°C and 45°C. Based on the experimental data, the heat transfer coefficient increases with increasing mass flux and fin helical angle, and with decreasing saturation temperature and Reynolds number of cooling water. In addition, the heat transfer coefficient of annular flow is greater than that of intermittent flow, in other words, the heat transfer coefficient increases with increasing vapor quality. The heat transfer coefficient obtained at high mass flux was compared with the calculated data of some published correlations used at low mass flux. It was found that most correlations underestimate the experimental heat transfer coefficient inside the micro-fin tube, and these prediction deviation increases with increasing mass flux and fin helical angle. By introducing some dimensionless numbers as well as considering the flow mechanism of liquid film inside the tube, two heat transfer coefficient correlations were proposed based on the experimental data. The ratio of liquid film thickness to fin height was used to characterize whether the liquid film flow is rotational flow or coexistence of rotational and horizontal flows in the proposed correlation, which shows a better prediction accuracy with a mean deviation of less than 7.3%.

EFFECT OF CONDENSING SURFACE WITH TEMPERATURE DIFFERENCE ON CONDENSATION HEAT TRANSFER FOR WATER-ETHANOL MIXTURES

Modeling Study on Heat Transfer in Marangoni Dropwise Condensation for Ethanol-Water Mixture Vapors

Effect of Non-Condensable Gas Mass Fraction on Condensation Heat Transfer for Water-Ethanol Vapor Mixture

Characterization of Marangoni Effect in Non-Isothermal Falling Liquid Films of Binary Mixtures

Condensate droplet growth characteristics of Marangoni condensation of ethanol–water mixtures on a horizontal surface

Experimental study of pressure drop during water–ethanol condensation in a vertical plate heat exchanger

Experimental Heat Transfer Coefficients for Zeotropic Mixture Condensation of Hexamethyldisiloxane/Octamethyltrisiloxane and Ethanol/Hexamethyldisiloxane

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Theoretical Analysis for the Condensation Heat Transfer of a Binary Vapor Mixture under the Thermal Equilibrium Condition.

Interfacial Effects on Nucleate Boiling Heat Transfer of Binary Mixtures

Exploring the limits of condensation heat transfer: A numerical study of microscale-confined condensation between parallel surfaces having wetting contrast

Experimental and analytical investigation on flow condensation heat transfer of zeotropic mixtures of tetrafluoromethane/ethane

Experimental study on condensation flow patterns and heat transfer characteristics of non-azeotropic and immiscible binary mixed vapors

Experimental research on non-azeotropic immiscible binary mixed vapors condensation mode and heat mass transfer characteristics under natural convection

Condensation characteristics of water vapor-CO 2 mixture outside horizontal circular tube

Visualization study of the influence of non-condensable gas on steam condensation heat transfer

Microscale Confinement and Wetting Contrast Enable Enhanced and Tunable Condensation.

Effects of the Heating Surface Structure of Phase Change Chamber on Boiling-Condensation Coexisting Phase Change Heat Transfer

Convective Boiling Heat Transfer of Methanol - Hydrogen Peroxide Solutions in a Microchannel Evaporator

Marangoni Effect on Hydrodynamics and Mass Transfer Behavior in an Internal Loop Airlift Reactor under Elevated Pressure

The enhancement effects of internal convection on the heat transport of condensing droplets out of pure steam and moist air