Abstract:The microstructure evolution of Ni-based superalloys during heat treatment is of great significance for obtaining better service performance. However, heat treatment experimentation is costly and time-consuming, and sometimes fails to reveal physical mechanisms well. In the present study, a multiphase-field model coupled with an explicit nucleation algorithm was established to simulate the precipitation and growth of γ′ phase in DD6 superalloy, which can be applied to a multicomponent elastic-inhomogeneous system. The PanNickel© database was used to calculate thermodynamic and kinetic data in multicomponent superalloys. First, the coupling method of multiphase-field model and explicit nucleation algorithm was introduced. The coupled model was used to simulate the precipitation of γ′ phase under isothermal and non-isothermal conditions. It was found that a unimodal microstructure was formed under isothermal conditions and there was a “soft impingement” phenomenon, while a bimodal distribution composed of cuboidal γ′ precipitates and fine secondary γ′ precipitates was formed during a cooling process of 25–125 °C/min. The effect of cooling rate was studied. Then, the chemical and elastic driving forces were analyzed. It was found that Al and Ta contributed most to the chemical driving force, while Re and W gathered at the γ/γ′ interface and inhibited the growth of γ′ phase. γ′ precipitates had a cuboidal shape under the influence of elastic driving force. Finally, the growth and coarsening process of γ′ phase was studied and compared with the well-known Lifshitz−Slyosov−Wagner (LSW) theory. The growth of γ′ phase can be divided into rapid growth, coarsening and quasi-static coarsening stages according to the simulation results, among which the coarsening stage is basically consistent with the LSW theory. The current model can be used to simulate the precipitation and growth of single crystal superalloys where multicomponent and elastic effects are considered.

Microscopic phase-field simulation of the gamma '(Ni3Al) phase separation process

Early Stages of Precipitation in Γ' Phase of a Ni–Al–Ti Model Alloy: Phase-Field and First-Principles Study

Atomic-scale computer simulation of mixture precipitation mechanism for Ni75AlxV25-x alloy

Microscopic Phase-Field Simulation for Correlations of Ni3Al Precipitates in Ni-Al Alloys

Inversion calculation of the interatomic potentials for Ni0.75AlxMo0.25-x alloy employing microscopic phase-field model

Phase-field simulation of evolution kinetics of second γ′ phase in Ni–Al alloy under tensile stress

Phase-field modeling of $γ/γ''$ microstructure formation in Ni-based superalloys with high $γ''$ volume fraction

Precipitate Behavior and Microstructure Evolution of Γ’ Phase in Ni-Al Alloys with the Internal Elastic Strain

COMPUTER SIMULATION FOR PRECIPITATION PROCESSO Ni_<75>Al_<2.5>V_<22.5> ALLOY WITH THE MICROSCOPIC PHASE-FIELD METHOD

Simulation of the precipitation process of Ni75AlxV25–x alloys incorporated in the microelasticity field

Hierarchical phase separation behavior in a Ni-Si-Fe alloy

Phase Field Modeling the Growth of Ni3Al Layer in the Β/γ Diffusion Couple of Ni–Al Binary System

Precipitation Sequence of Middle Al Concentration Alloy Using the Inversion Algorithm and Microscopic Phase Field Model

A Correlative Four-Dimensional Study of Phase Separation at the Subnanoscale to Nanoscale of a Ni-Al Alloy

Microscopic phase-field study on L12 interface properties of Ni75Al18Cr7 superalloy

Morphological, nanostructural, and compositional evolution during phase separation of a model Ni-Al-Mo superalloy: Atom-probe tomographic experiments and lattice-kinetic Monte Carlo simulations.

Precipitation and Growth Simulation of Γ′ Phase in Single Crystal Superalloy DD6 with Multiphase-Field Method and Explicit Nucleation Algorithm

Stability of phase boundary between L12-Ni3Al phases: A phase field study

Phase-Field Simulation of the Effect of Interaction among Ordered Domains on Interdiffusion in Ni-Al-Cr Alloys

Phase-field study for the pre-precipitation process of L12-Ni3Al phase in Ni–Al–V alloy

Phase-field simulation of re-dissolution of γ′ phase in Ni–Al alloy by continuous and second-order aging treatment