Abstract:For coal semi-char as a by-produced of low-temperature pyrolysis, combustion for power generation is one of the effective utilization methods to realize its clean and efficient utilization. However, the coal semi-char combustion process has a difficult ignition, unstable combustion and low burnout rate. The co-firing of the semi-char with biomass under oxy-fuel conditions can improve the combustion behavior and reduce fossil CO2 emissions. In this paper, the combustion behavior of Shenhua coal semi-char (SHC) co-firing with straw (ST) in O2/CO2 mixture is investigated using thermogravimetric analysis. The results show that each curve lays between those of the individual fuels and presents three peaks (i.e., three stages). The thermogravimetric curves of SHC co-firing with ST can be divided into three stages: the volatile combustion of ST, the co-combustion of SHC and ST fixed-carbons and the SHC fixed-carbon combustion and the decomposition of the difficult pyrolytic material of ST. Blending ST into the SHC can significantly decrease the ignition temperature and improve the comprehensive combustion behavior of blended samples. In increasing the proportion of ST from 25 to 100%, the change of the blended ignition temperature is slight, but the burnout temperature decreases greatly. Kinetic parameters of combustion are calculated by using the Coats–Redfern integral method. Compared to that of stage I and stage III, the activation energy of stage II is significantly lower. As increasing blending ratio from 25% to 100%, the activation energy increases at stage I and decreases at stage III. Furthermore, the O2 concentration obviously affects stage III of 50% SHC + 50% ST, and the thermogravimetric curves at this stage are obviously shifted to the lower temperature zone as the O2 concentration increases. The activation energy of 50% SHC + 50% ST increases as the oxygen concentration increases. Besides, the activation energy shows that the combustion characteristics cannot be determined only by the activation energy obtained by the Coats–Redfern method. These findings can provide useful information for semi-char co-firing with biomass.

Thermo-gravimetric Study and Kinetic Analysis of Blended Combustion Characteristics of Oil Shale and Semi-Coke

Combustion kinetics study of oil shale semi-coke

STUDY ON COMBUSTION PROPERTY OF MIXTURE OF OIL SHALE AND HESHAN COAL

Kinetic Study on Co-Combustion of Pulverized Anthracite and Bituminite for Blast Furnace Injection

Non-isothermal Thermogravimetric Investigation on Mutual Effect Between Bituminite and Anthracite in Blends for Blast Furnace Injection

Study of the combustion mechanism of oil shale semicoke in a thermogravimetric analyzer

Catalytic Effects on Combustion Behavior of Oil Shale: Thermal Conversion, Kinetic, Mechanism Analyses

Thermogravimetric Analysis of Coal Semi-Char Co-Firing with Straw in O2/CO2 Mixtures

Investigation on co-combustion of semi-coke and bituminous coal in oxygen-enriched atmosphere: Combustion, thermal conversion, and kinetic analyses

Two-dimensional Combustion Modelling and Experimental Research on Oil Shale Semicoke

Experimental investigation on ignition and burnout characteristics of semi-coke and bituminous coal blends

Co-combustion kinetics characteristics of semi-coke and bituminous coal under a drop tube furnace

Co-combustion of Coal and Carbonaceous Wastes: Thermogravimetric Analysis

Investigation on the co-combustion of oil shale and municipal solid waste by using thermogravimetric analysis

Kinetic study on the pyrolysis behavior of Huadian oil shale via non-isothermal thermogravimetric data

Thermo-gravimetric Research on Dynamic Combustion Reaction Parameters of Blended Coals

Experimental investigation on co-combustion characteristics of semi-coke and coal: Insight into synergy and blending method

Laminar Combustion Characteristics of Premixed Shale Gas and Air Flames

Pyrolysis characteristics of oil shale semi-coke and its extracted bitumen

Thermogravimetric Analysis On The Combustion Characteristics For Blended Coals

Study of the Kinetic Behaviour of Biomass and Coal During Oxyfuel Co-Combustion