Abstract:Model Experiments including steady-state and hydraulic transient experiments are essential to study the hydraulic characteristics of pump turbines in turbine mode. They can be used as verification of CFD calculations. Moreover, some special and complicated transient processes can only be examined through experimental research. This paper reports a series of steady-state and hydraulic transient experiments performed on an open-loop pumped storage test rig. First of all, steady-state experimental results were presented, including the measured characteristic curves by adjusting the sphere valve, characteristics of pressure pulsations, and the hill-chart. Subsequently, three kinds of transient experiments were conducted under a fixed guide-vane opening (GVO) to dynamically investigate characteristic curves. The first kind of dynamic tests was conducted with continuous operation of the sphere valve while the unit rotated at the rated value by connecting to the power grid. This was followed by the load rejection experiments. In the third type of transient experiments, the recirculation pump delivering water to the upstream and downstream tanks was shut down when the unit was in designed operation and synchronized to the power grid. As the water level in the upstream tank continued to decrease, the unit experienced a special dynamic process. In this process, the flow discharge and the water head were oscillating periodically while the pump-turbine was switching back and forth from the turbine mode to the reverse rotation pump mode with a constant rotational speed. This transient test was completely different from the others and was regarded as an individual method to investigate the characteristic curves dynamically. Finally, characteristics curves under a constant GVO obtained by these tests were compared and analyzed.

Transient Simulation of the Hydropower Station with Impulse Water Turbine

Transient Simulation Of Hydropower Station With Consideration Of Three-Dimensional Unsteady Flow In Turbine

Transient simulation of turbine jointed with diversion penstock

Transient simulation coupling model of transient pipe flow and three-dimensional flow in turbine

Transient Flow Dynamics Analysis of a Large Prototype Francis Turbine at Different Loads

Transient simulation with mixed free surface pressure flow for right bank underground hydropower station of the Three Gorges

Transient Simulation with MFSPF for Right Bank Underground Hydropower Station of the Three Gorges

Three dimensional flow simulation of load rejection of a prototype pump-turbine

Three-dimensional Unsteady Simulation of the Runaway Transient of the Francis Turbine

3D Unsteady Turbulent Simulation of the Runaway Transient of the Francis Turbine

Basic Modeling and Simulation Tool for Analysis of Hydraulic Transients in Hydroelectric Power Plants

Simulation and optimum design of transient mixed free-surface-pressure flow for the hydropower station

CFD simulation of the pump trip runaway transient process of a pumped-storage power plant with head 700 m

Steady and transient performance of a model pump-turbine at off-design conditions: turbine mode

Numerical Simulation on Pump Transient Characteristic in a Model Pump Turbine

Three-dimensional Flow Simulation of Transient Power Interruption Process of a Prototype Pump-Turbine at Pump Mode

Simulation of transient mixed free-surface-pressure flow

Numerical Simulation of the Transient Process of Power Failure in A Mixed Pump

Experimental research and turbulent flow simulation of the updraft free-exit-flow hydropower turbine system

Unsteady Turbulent Simulation of Three Gorges Hydraulic Turbine and Analysis of Pressure in the Whole Passage

Numerical Simulation of the Transient Flow in a Pump-Turbine During the Load Rejection Process With Special Emphasis on the Cavitation Effect