Abstract:Partial admission is applied wildly to regulate the power in turbomachinery. The prominent unsteady characteristic has a great effect on the aerodynamic performance and unit safety. The RNG k-ε turbulence model, dual time step method, sliding interface model and structural hexahedron mesh were adopted and the 3-D unsteady viscous model for the full annulus of the control stage of 300MW steam turbine with admission room and reinforced rib was constructed. The flow phenomena and exciting force were investigated detailed in multiple working conditions. The time-averaged unsteady wheel efficiency is over 3% lower than that from steady analysis with two different degrees of admission. The rotor blades experience large unsteady axial and tangential forces while passing the blocked channel. Spectrum analysis was performed and 50.0Hz is seen as the typical low frequencies. The largest amplitude of unsteady forces under the condition of three valves opened (ξ = 0.70) is at the first multiple rotational frequency due to the circumferential nonuniformities of flow domain, while the largest amplitude under the condition of two valves opened (ξ = 0.47) is at the second multiple rotational frequency due to the circumferential periodicities of flow domain. These provide essential parameters for strength and vibration analysis of blade. The pressure and static entropy plots show that the circumferential distributions are nonuniform and the nonuniformities decrease while moving towards the downstream sections in the two conditions. The entropy is significantly large, which means that the mixing and windage losses are huge resulting in the decrease of the blade power. The pressure drop moves towards the downsteam blade surface while rotor passing into the blocked channel. The pressure is recovering while rotor passing out the blocked channel.

3D Unsteady Turbulent Simulation of the Runaway Transient of the Francis Turbine

Three-dimensional Unsteady Simulation of the Runaway Transient of the Francis Turbine

Unsteady flow characteristics during runaway process in Francis turbine: Insights from numerical investigation

THREE DIMENSIONAL UNSTEADY SIMULATION OF A MODEL FRANCIS HYDRAULIC TURBINE

Three-dimensional CFD Simulation of the Runaway Transients of a Propeller Turbine Model

Transient Flow Dynamics Analysis of a Large Prototype Francis Turbine at Different Loads

Numerical Analysis of Unsteady Flow under High‐head Operating Conditions in Francis Turbine

Turbulent Simulation of Francis Turbine with 3D Guide Vanes

Numerical Analysis on Pump Turbine Runaway Points

Numerical Simulation of Unsteady Flow Phenomena and Exciting Force in Control Stage of Steam Turbine under Multiple Working Conditions

UNSTEADY NUMERICAL SIMULATION OF CONTRA-ROTATING KAPLAN TURBINE

Vorticity Dynamics Analysis On Flow In Francis Hydraulic Turbine

Numerical Predictions and Stability Analysis of Cavitating Draft Tube Vortices at High Head in a Model Francis Turbine

Numerical Simulation Of 3d Cavitating Turbulent Flow In Francis Turbine

Flow Simulation and Diagnosis Through Hydraulic Turbines Using a RNG k-ω Turbulence Model

3-D Unsteady Flow Field Numerical Simulation of Whole Flow Passage in Francis Turbine

Simulation of unsteady flow in a Francis turbine draft tube

Experimental and Numerical Analysis of Pressure Pulses Characteristics in A Francis Turbine with Partial Load

Dynamic Characteristics of a Running Away Pump-Turbine with Large Head Variation: 1D + 3D Coupled Simulation

Analysis of CFD for the Vortex Rope in the Draft Tube Urged by the Long and Short Blades Runner

Simulation of Unsteady Flow Induced by in Vortices the Draft Tube of a Francis Turbine