Abstract:This paper explored a kind of fiber reinforced polymer (FRP)/shape memory alloy (SMA) composite prestressed strengthening system, and studied the prestress loss and flexural behavior of precracked reinforced concrete (RC) beams strengthened with FRP/SMA composites by experiments. In the experiment, the length ratio of SMA wires to FRP sheets, the type of FRP sheets, and the area ratio of SMA wires to FRP sheets were selected as the main parameters. The prestress loss test results indicated that the elongation of FRP sheets in the strengthening zone, relative slip between SMA wires and FRP sheets, and crack closure are the main causes of prestress loss in beams strengthened with FRP/SMA composites. Among these, the prestress loss caused by the elongation of FRP sheets in the strengthening zone accounted for a significant proportion of the total loss, while the remaining two losses accounted for a minor proportion. The increase of the length ratio of SMA wires to FRP sheets could effectively reduce the prestress loss due the decrease of SMA shrinkage strain. The type of FRP sheets in the strengthening zone affected the prestress loss mainly by affecting the elongation of FRP sheets. The area ratio of SMA wires to FRP sheets influenced the total recovery force level. The prestress loss mainly occurred within 12 hours (initial curing of epoxy resin) after thermal activation of SMA wires, and then the prestress loss was small in the following 60 hours (complete curing of epoxy resin). The flexural test results of beams strengthened with FRP/SMA composites showed that the flexural capacity was significantly improved, and the yield and ultimate load significantly increased. At the same time, the service performance was also improved due to the introduction of SMA wire recovery stress. In addition, the introduction of prestress to FRP sheets in the strengthening zone delayed the debonding failure induced by the crack. Lastly, the sectional analysis method was also applied to predict the load-deflection responses of the strengthened beams, which was validated through comparisons with the test results.

Experimental study on the flexural behavior of RC beams strengthened with prestressed stainless steel wire mesh and permeability polymer mortar

Experimental Study on Flexural Behavior of RC Beams Strengthened with Stainless Steel Wire Mesh and Permeability Polymer Mortar

Investigation on Flexural Performance of RC Beams Flexurally Strengthened by Side-bonded CFRP Laminates

Experimental Investigation on First Crack Strength and Crack Widthof Reinforced Concrete Beamsby Side-Bonding Cfrp Sheets

Experimental Study on RC Beams Strengthened by a Novel Large Diameter Pre-stressed Stainless Steel Wire Mesh – Mortar Structure

Study on flexural performance of cracked RC beams retrofitted with CFRP sheets

Behavior of Preloaded RC Beams Strengthened with CFRP Laminates

Effect of sustaining load level on flexural behavior of RC beams retrofitted with CFRP sheets

Strengthening RC Beams with Mid-Span Supporting Prestressed CFRP Plates: an Experimental Investigation

Investigation On Flexural Behavior Of Reinforced Concrete Beams Flexurally Strengthened By Different Methods

Study on the Test of RC Beam Bridge Strengthed with Prestressed SSWM-M Technology

Experimental study on RC beams shear‐strengthened with composite polymer mortar and steel strands wire mesh

CFRP Strengthened RC Beams with Pre-Strengthening Non-Uniform Reinforcement Corrosion Subjected to Post-Strengthening Wetting/drying Cycles

Experimental study on flexural behavior of RC beams strengthened with FRP/SMA composites

Experimental study on simply supported RC beams strengthened by steel plate-concrete composite technique

Investigation of the flexural behavior of reinforced concrete beams strengthened with a composite reinforcement layer: Polyvinyl alcohol fiber‐reinforced ferrocement cementitious composite and steel wire mesh

Prestress loss and flexural behavior of precracked RC beams strengthened with FRP/SMA composites

Experimental study and analysis of RC beams shear strengthened with FRP/SMA composites

Flexural behavior of RC beams strengthened with fully or partially prestressed near-surface mounted FRP strips: An experimental investigation

Analysis on Stress and Short-term Flexural Stiffness of Strengthened RC Beam Prestressed with CFRP Sheets

Study on reinforced concrete beams strengthened using shape memory alloy wires in combination with carbon-fiber-reinforced polymer plates