Abstract:To improve the oil conversion, high methanol/oil molar ratio is required in the continuous production of biodiesel via supercritical methanol transesterification in tubular reactor. And thus the subsequent excess methanol recovery needs high energy consumption. Based on the feature of high temperature and high pressure in supercritical methanol transesterification, excess methanol recovery in reaction system by flashing vaporation is conducted and the effect of reaction temperature, reaction pressure and flashing pressure on methanol recovery and methanol concentration in gas phase is discussed in detail in this article. Results show that at the reaction pressure of 9-15 MPa and the reaction temperature of 240-300 degrees C, flashing pressure has significant influence on methanol recovery and methanol content in gas phase, which can be effectively improved by reducing flashing pressure. At the same time, reaction temperature and reaction pressure also have an important effect on methanol recovery and methanol content in gas phase. At volume flow of biodiesel and methanol 1:2, tubular reactor pressure 15 MPa, tubular reactor temperature 300 degrees C and the flashing pressure 0.4 MPa, methanol recovery is more than 85% and methanol concentration of gas phase (mass fraction) is close to 99% after adiabatic braising; therefore, the condensate liquid of gas phase can be injected directly into methanol feedstock tank to be recycled.Research abstracts: Biodiesel is an important alternative energy, and supercritical methanol transesterification is a new and green technology to prepare biodiesel with some obvious advantages. But it also exists some problems: high reaction temperature, high reaction pressure and large molar ratio of methanol/oil will cause large energy consumption which restricts supercritical methanol for the industrial application of biodiesel. So a set of tubular reactor-coupled flashing apparatus is established for continuous preparing biodiesel in supercritical condition and separation of excess methanol, which provides an appropriate method to solve the separation and recycle of excess methanol and waste heat utilization. (C) 2010 Elsevier Ltd. All rights reserved.

Production Of Biodiesel And Glycerol From Biomass By Supercritical Fluid Technology

Production process of biodiesel and glycerol by supercritical fluid technology

PROGRESS IN PRODUCTION OF BIODIESEL IN SUPERCRITICAL METHANOL

Preparation of biodiesel using supercritical fluid techniques

Continuous production of biodiesel fuel from vegetable oil using supercritical methanol process

Continuous Production of Biodiesel from Soybean Oil Using Supercritical Methanol in A Vertical Tubular Reactor: I. Phase Holdup and Distribution of Intermediate Product along the Axial Direction

Preparation of Biodiesel Fuel with Supercritical Methanol

Research Advances in Preparation of Biodiesel Fuel Using Spercritical Techniques

Production of biodiesel in supercritical methanol and related correlation on phase equilibrium

Simulation Analysis of Methanol Flash Distillation Circulation Process in Biodiesel Production with Supercritical Method

Continuous preparation of biodiesel under supercritical methanol condition

The Primary Study of Continuous Preparation of Biodiesel under Supercritical Condition

Co-solvent THF effect on continuous production of biodiesel from soybean oil using supercritical methanol

A review of multi-phase equilibrium studies on biodiesel production with supercritical methanol

Component Confirmation and Process of Biodiesel Produced in Supercritical Conditions with Addition of Tiny KOH

Experimental Study on Methanol Recovery Through Flashing Vaporation in Continuous Production of Biodiesel Via Supercritical Methanol

Continuous Production of Biodiesel Via Supercritical Methanol Transesterification in a Tubular Reactor. Part 1: Thermophysical and Transitive Properties of Supercritical Methanol

Process optimization, kinetic and thermodynamic studies on biodiesel production by supercritical methanol transesterification with CH3ONa catalyst

A review of multi-phase equilibrium study on biodiesel production with supercritical methanol

A review of transesterification from low-grade feedstocks for biodiesel production with supercritical methanol

Sustainable Utilization of Crude Glycerol from Biodiesel Production: Catalyst Free Monoacyglycerols Production