Abstract:To obtain a high biodiesel yield, the conditions of transesterification of vegetable oil with supercritical methanol are harsh. The reaction temperature is required between 350 and 400 °C, and the reaction pressure is required above 20 MPa. To reduce the operating temperature and pressure, many researchers adopted various methods, such as the selection of a new reactor, the addition of a co-solvent, or the usage of microwave irradiation. According to the characteristics of transesterification, a small amount of organic or inorgnic acid was added into the reaction system, and the effects of an acidic condition on transesterification was investigated in this paper. The experiment was conducted in a continuous flow tubular reactor; the temperature ranged from 270 to 350 °C; the pressure covered the range from the normal pressure to 15 MPa; the molar ratio of methanol/oil was from 20:1 to 60:1; and the acidity of acidified soybean oil was from 5 to 30 mg of KOH/g. The results showed that the higher yield of biodiesel was obtained at the conditions with the addition of acid compared to the corresponding conditions without acid and the increase of the yield was more remarkable under lower pressure and temperature correspondingly. Besides, it was found that the effect of inorgnic acid on transesterification was more obvious than that of organic acid. The yield of biodiesel could reach 91.4% when the reaction temperature, the reaction pressure, the methanol/oil molar ratio, and the acidity of acidified soybean oil were 350 °C, 15 MPa, 40:1, and 15.0 mg of KOH/g, respectively. It was also revealed that the transesterification reaction was still controlled by reaction kinetics to a great degree, although the reaction had reached the supercritical status.

Transesterification Kinetics of Soybean Oil for Production of Biodiesel in Supercritical Methanol

Reaction Kinetics of Transesterification between Vegetable Oil and Methanol under Supercritical Conditions

Esterification of free fatty acids with supercritical methanol for biodiesel production and related kinetic study

Effect of Weak Acids As a Catalyst on the Transesterification of Soybean Oil in Supercritical Methanol

Process optimization, kinetic and thermodynamic studies on biodiesel production by supercritical methanol transesterification with CH3ONa catalyst

Kinetics of Transesterification Crude Soybean Oil to Biodiesel Catalysed by Magnesium Methoxide

Continuous preparation of biodiesel under supercritical methanol condition

Esterification kinetics of free fatty acids with supercritical methanol for biodiesel production

Production of biodiesel in supercritical methanol and related correlation on phase equilibrium

The Primary Study of Continuous Preparation of Biodiesel under Supercritical Condition

Novozyrn 435-Catalysed Transesterification Of Crude Soya Bean Oils For Biodiesel Production In A Solvent-Free Medium

Continuous Production of Biodiesel from Soybean Oil Using Supercritical Methanol in A Vertical Tubular Reactor: I. Phase Holdup and Distribution of Intermediate Product along the Axial Direction

Lipase-mediated methanolysis of soybean oils for biodiesel production

Continuous production of biodiesel fuel from vegetable oil using supercritical methanol process

Production process of biodiesel and glycerol by supercritical fluid technology

Co-solvent THF effect on continuous production of biodiesel from soybean oil using supercritical methanol

PROGRESS IN PRODUCTION OF BIODIESEL IN SUPERCRITICAL METHANOL

Preparation of Biodiesel Fuel with Supercritical Methanol

Combustion dynamics of biodiesel produced by supercritical methanol transesterification

Biodiesel from Rapeseed via Extraction and in-situ Transesterification in Supercritical Methanol

Simulation Analysis of Methanol Flash Distillation Circulation Process in Biodiesel Production with Supercritical Method