Abstract:Mangano-manganic oxide can be prepared through thermal decomposition of manganese sulfate from the absorption or leaching solution, so desulfurization by pyrolusite or leaching pyrolusite with sulfur dioxide should be fully exploited for the recovery of manganese salt. However, upon preparing MnSO4 using above techniques, manganese dithionate is an inevitable by-product, which lowers the purity of the industrial raw material MnSO4 and exerts negative influences on pyrolysis technology. Information regarding thermal decomposition of solid-state manganese dithionate is scarce. To recycle manganese dithionate efficiently, pyrolysis mechanism and kinetics were systematically investigated by thermal decomposition method. The characteristics of thermal decomposition products were determined by thermogravimetric analysis techniques (TG), X-ray diffraction (XRD), and Ion chromatography (IC). The experimental results revealed that both desulfurization and following dehydration of MnS2O6H2O were a one-step process, and the desulfurization occurred at about 150 degrees C lower than the dehydration at 230 degrees C. As increasing pyrolysis temperature to 900 degrees C, the manganese sulfate was firstly formed, and to 1100 degrees C, Mangano-manganic oxide was obtained by losing sulfur oxides. Consequently, the kinetic parameters for each decomposition steps of manganese dithionate were determined by the Coasts and Redfern (CR) integral method. The as-obtained experimental and kinetic results may provide theoretical guides for recycling manganese dithionate.

Crystallization Behavior And Thermal Decomposition Characteristics Of Manganese(Ii) Oxalate In Organic-Water Binary Solvent System

Synthesis of Porous Manganese Oxides Bars Via A Hydrothermal-Decomposition Method

Hydrothermal Preparation and Characterization of MnWO4Nanowires

Synthesis and Characterization of Single Crystalline Mnooh and Mno2 Nanorods by Means of the Hydrothermal Process Assisted with Ctab

Physicochemical characterizations and semiconducting properties of a manganese tungstate MnWO4 obtained by hydrothermal route

Study on a structure of Manganese Oxide, Mn3O6(H2O)2

Crystal Structure and Thermal Property of a Binuclear Manganese(II) Sulfate Complex with Carbohydrazide

Ionic Liquids Assisted Preparation of Manganese Dioxide and Its Catalytic Properties

Morphology-controlled Synthesis and Characterization of MnWO4 Nanocrystals Via a Facile, Additive-Free Hydrothermal Process

Formation and Conversion Mechanisms Between Single-Crystal Gamma-Mnooh and Manganese Oxides

Controllable Synthesis, Characterization, and Electrochemical Properties of Manganese Oxide Nanoarchitectures

Synthesis, structural investigation and thermal properties of a novel manganese complex Mn2(DAT)2Cl4(H2O)4 (DAT=1,5-diaminotetrazole).

Study on a Structure of Manganese Oxide, Mn<sub>3</sub>O<sub>6</sub>(H<sub>2</sub>O)<sub>2</sub>

Manganese oxides with different crystalline structures: Facile hydrothermal synthesis and catalytic activities

Tuning the crystallinity of MnO2 oxidant to achieve highly efficient pollutant degradation

Thermal and Kinetic Study of Manganese Dithionate from Absorbing or Leaching Solution Via TG/XRD/IC Analysis

Hydrothermal Preparation of Nanostructured MnO2 and Morphological and Crystalline Evolution

One-dimensional structure and long-range antiferromagnetic behaviour of manganese (II) oxalate trihydrate: {[Mn(μ-ox)(H2O)2]·H2O}n

Mn3o4: Solvo-Thermal Synthesis And Crystallization Kinetics

A simple method to synthesise single-crystalline manganese oxide nanowires

Crystal phase-driven performance of MnO2 in aqueous phase low-temperature thermal catalysis: Synergistic interactions between Mn3+ and surface lattice oxygen