Abstract:Structural and phase transformations in the microstructure and new metastable baro- and deformation-induced phases of the Ni50Mn28.5Ga21.5 alloy, typical of the unique class of ferromagnetic shape memory Heusler alloys, have been systematically studied for the first time. Phase X-ray diffraction analysis, transmission and scanning electron microscopy, and temperature measurements of electrical resistivity and magnetic characteristics in strong magnetic fields were used. It was found that in the course of increasing the pressure from 3 to 12 GPa, the metastable long-period structure of martensite modulated according to the 10M-type experienced transformation into a final non-modulated 2M structure. It is proved that severe shear deformation by high pressure torsion (HPT) entails grainsize refinement to a nanocrystalline and partially amorphized state in the polycrystalline structure of the martensitic alloy. In this case, an HPT shear of five revolutions under pressure of 3 GPa provided total atomic disordering and a stepwise structural-phase transformation (SPT) according to the scheme 10M → 2M → B2 + A2, whereas under pressure of 5 GPa the SPT took place according to the scheme 10M → 2M → B2 → A1. It is shown that low-temperature annealing at a temperature of 573 K caused the amorphous phase to undergo devitrification, and annealing at 623-773 K entailed recrystallization with the restoration of the L21 superstructure in the final ultrafine-grained state. The size effect of suppression of the martensitic transformation in an austenitic alloy with a critical grain size of less than 100 nm at cooling to 120 K was determined. It was established that after annealing at 773 K, a narrow-hysteresis thermoelastic martensitic transformation was restored in a plastic ultrafine-grained alloy with the formation of 10M and 14M martensite at temperatures close to those characteristic of the cast prototype of the alloy.

First Principles Calculations on Martensitic Transformation and Phase Instability of Ni–Mn–Ga High Temperature Shape Memory Alloys

Martensitic Transformation And Phase Stability Of In-Doped Ni-Mn-Sn Shape Memory Alloys From First-Principles Calculations

First-principles investigation of magnetic property and defect formation energy in Ni-Mn-Ga ferromagnetic shape memory alloy

Martensitic Transition and Electronic, Magnetic, Thermal, and Thermoelectric Properties of Metallic Ferromagnetism Ni2Mn1-xGa1-yFex+y Shape Memory Alloys: Ab Initio Calculations

Defect formation energy and magnetic properties of off-stoichiometric Ni-Mn-In alloys by first-principles calculations

Influence of β-Stabilizing Nb on Phase Stability and Phase Transformation in Ti-Zr Shape Memory Alloys: From the Viewpoint of the First-Principles Calculation

Effect of Alloying Element Al Substitution on Ni-Mn-Sn Shape Memory Alloy by First-Principle Calculations

Magnetic Properties and Structural Phase Transformations of NiMnGa Alloys

High-temperature Metamagnetic Martensitic Transformation in Fairly Mn-rich Ni50−Co Mn37Ga13 (0 ≤x≤ 50) Alloys

A model of phase transition from austenite to martensite in single-crystal NiMnGa alloys

Inversion calculation of the interatomic potentials for Ni0.75AlxMo0.25-x alloy employing microscopic phase-field model

Manipulation of microstructure evolution and deformation behavior in Ni–Mn–Ga shape memory alloys with varied Ni/Ga under uniaxial cyclic compression

Composition-dependent phase transformation path involving 4O martensite in Ni–Mn–Sn magnetic shape memory alloys

Unified physical mechanism for martensitic phase transition and ductility in Ni–Mn-based ferromagnetic shape memory alloys: the case of Cu-doped Ni2MnGa

Microstructure, Phase Transformation and Mechanical Property of Nb-doped Ni–Mn–Ga Alloys

Martensitic transformation, mechanical and magnetic properties of Ni-Cu-Mn-Ti-(B) Heusler alloys by first-principles investigations

Anomalous martensitic transformation with diffusion in the all- d -metal Heusler alloys of Ni 2 MnTi and Ni 2 MnV from first-principles investigation

Martensitic Transformation and Magnetic Properties in High-Mn Content Mn50Ni50−xInx Ferromagnetic Shape Memory Alloys

Ab initio investigation of the martensitic phase transitions in ternary high temperature shape memory alloys

New Metastable Baro- and Deformation-Induced Phases in Ferromagnetic Shape Memory Ni2MnGa-Based Alloys

First-principles calculations of Ni-(Co)-Mn-Cu-Ti all-d-metal Heusler alloy on martensitic transformation, mechanical and magnetic properties