Abstract:The large current ripple caused by the limited switching frequency significantly degrades the control performance of the high-speed permanent magnet motor drive system. To mitigate the current ripple, the switching frequency of the inverter should be high enough. The purpose of this article is to reduce the current ripple of the HSPMSM drive system. First, a Silicon-Carbide/Silicon(SiC/Si) hybrid inverter is designed. The designed hybrid inverter consists of two SiC-MOSFETs and six Si-IGBTs, and the circuit modals of the SiC/Si hybrid inverter are analyzed. Second, based on the SiC/Si hybrid inverter, three improved space-vector-modulation (SVM) strategies are proposed. The core principle of the proposed SVM strategies is that most of the switching actions are transferred from the Si-IGBTs to the SiC-MOSFETs. The benefit from the low switching loss of the SiC device is that the total power loss can be significantly reduced. Besides, the SiC-MOSFETs can create the zero-voltage-switch condition for the Si-IGBTs, and then the switching loss of the Si-IGBTs can be almost eliminated. Finally, to verify the effectiveness of the proposed methods, sufficient simulations and experiments are implemented. The stator current ripple, total-harmonic-distortion, and the conversion efficiency of the inverter in the full power range are compared under the same condition based on the full-Si-IGBT inverter, the full-SiC-MOSFET inverter, and the SiC/Si hybrid inverter. The evaluated results sufficiently verify the superiority of the proposed SiC/Si hybrid inverter and the improved SVM strategies.

Design of the Inverter of High-Current Capability for PMSM under Low DC Voltage Supply

Design and Simulation of a PFM-PWM Hybrid Controller for DCDC Converter with CLLC Topology

Open Winding PMSM System for Electric Vehicles Collaboratively Supplied by the Z-Source and Voltage Source Converters

Design of Single-phase Low-power Grid-Connected Inverter for Distributed Generation

A high efficient 33 level inverter for electric vehicle application using PMSM

A Sensorless Drive Strategy for Open-End Winding PMSM with Common DC Voltage Based on Lower Switching Frequency

Control Strategy for Open Winding PMSM System Supplied by the Z-source and Voltage Source Integrated Converters

A Constant-Current Power Supply Inverter Applied to a Test System for the Magnetic Performance of the Core

Research on Techniques of Three-level Six-phase Synchronous Motor Driver

High Power Integrated Charging System For Electrical Vehicles Based On Winding Multiplexing Of Pmsm

A Novel SVPWM Scheme for Field-Oriented Vector-Controlled PMSM Drive System Fed by Cascaded H-Bridge Inverter

A boost converter-based CSI-fed PMSM drives with common-mode voltage suppression for low-input voltage application

A Symmetrical Hybrid Five-Level Inverter for High-speed PMSM Drives

Analyzing and Designing of Drive System for PMSM under Low Voltage

High Power Traction Inverter Design and Comparison for Electric Vehicles

A Three-level Drive Control Method Based on High-speed Permanent Magnet Synchronous Motor

A HYBRID 9-LEVEL VOLTAGE SOURCE INVERTER AND PWM STRATEGY

Simplified PWM for Fault Tolerant Control of Open Winding PMSM Fed by Hybrid Inverter

Control Method of PMSM Driving System with Small DC-Link Capacitor

Influence of High-Frequency Operation on the Efficiency of a PMSM Drive with SiC-MOSFET Inverter

Evaluation of Three Improved Space-Vector-Modulation Strategies for the High-Speed Permanent Magnet Motor Fed by a SiC/Si Hybrid Inverter