Abstract:Experimental and numerical studies were conducted to reveal the flow and heat transfer characteristics of liquid laminar flow in microtubes. Both the smooth fused silica and rough stainless steel microtubes were used with the hydraulic diameters of 50–100μm and 373–1570μm, respectively. For the stainless steel tubes, the corresponding surface relative roughness was 2.4%, 1.4%, 0.95%. The experiment was conducted with deionized water at the Reynolds number from 20 to 2400. The experimental data revealed that the friction factor was well predicted with conventional theory for the smooth fused silica tubes. For the rough stainless steel tubes, the friction factor was higher than the prediction of the conventional theory, and increased as the surface relative roughness increased. The results also confirmed that the conventional friction prediction was valid for water flow through microtube with a relative surface roughness less than about 1.5%. The experimental results of local Nusselt number distribution along the axial direction of the stainless steel tubes do not accord with the conventional results when Reynolds number is low and the relative thickness of the tube wall is high. The numerical study reveals that the large ratio of wall thickness over tube diameter in low Reynolds number region causes significant axial heat conduction in the tube wall, leading to a non-linear distribution of the fluid temperature along the axial direction. The axial heat conduction effect is gradually weakened with the increase of Reynolds number and the decrease of the relative tube wall thickness and thus the local Nusselt number approaches the conventional theory prediction.

EXPERIMENTAL STUDY OF TRANSITIONAL AND TURBULENT FLOW IN A MICROTUBE

Transitional and turbulent flow in a circular microtube

Experimental Study on Transitional Flow in A Circular Microtube

An Experiment-Based Comparative Investigation of Correlations for Microtube Gas Flow

Experimental Investigation on Flow and Heat Transfer in Rough Microtube

Experimental study on influence of microscale effects on liquid flow characteristic in microtubes

Experimental Study and Analysis About Flow and Heat Transfer in Micro-tubes

Numerical Investigation On The Effect Of Roughness On The Flow Resistance For Incompressible Fluid Flow In Microtubes

EXPERIMENTAL STUDY OF LIQUID FLOW AND HEAT TRANSFER IN MICROTUBES

Experimental and Numerical Studies of Liquid Flow and Heat Transfer in Microtubes

The Study on the Flow of the Kerosene in Micro Tube

NUMERICAL SIMULATION OF FLOW TRANSITION IN A RECTANGULAR MICROCHANNEL

Experimental study on flow characteristics of liquid in circular microtubes

Experimental Investigation On Flow Condensation Heat Transfer In Microtube

Experimental study on friction characteristics in microtube

Effect of Reversible Work and Viscous Dissipation on Gas Flow Characteristics in a Microtube

Variations in gas temperature and average velocity during laminar-turbulent transition in high-speed gas flow through microtubes

Transitional And Turbulent Convective Heat Transfer Of Compressible Gas Flows Through Microtubes

Experimental Study on Flow and Heat Transfer in a 19.6-Μm Microtube

Experimental Study of Single-Phase Pressure Drop and Heat Transfer in a Micro-Fin Tube

Friction resistance for gas flow in smooth microtubes