Abstract:Pilot tests were carried out on a I MW thermal pulverized coal fired testing furnace. Symmetrical combustion was implemented by use of two whirl burners with dual air adjustment. The burnout air device was installed in various places at the top of the main burner, which consists of a primary air pipe with a varying cross-section and an impact ring. In the primary air pipe, the air pulverized coal (PC) stream was separated into a whirling stream that was thick inside and thin outside, thus realizing the thin-thick distribution at the burner nozzle in the radial direction. From the comparative combustion tests of three coals with relatively great characteristic differences, Shaanbei Shenhua high rank bituminous coal (SH coal), Shanxi Hejin low rank bituminous coal (HJ coal), and Shanxi Changzhi meager coal (CZ coal), were obtained such test results as the primary air ratio, inner secondary air ratio, Outer secondary air ratio, impact of the change of outer secondary air, change of the relative position for the layout of burnout air, change of the swirling intensity of the primary air and secondary air, etc., on the NOx emission, and unburnt carbon content in fly ash (C-FA). At the same time, the relationship between the NOx emission and burnout ratio and affecting factors of the corresponding test items oil the combustion stability and economic results were also acquired. The results may provide a vital guiding significance to engineering designs and practical applications. According to the experimental results. the influence of each individual parameter oil NOx formation and unburned carbon in fly ash agrees well with the existing literature. In this study, the influences of various combinations of these parameters are also examined, thus providing some reference for the design of the radial biased swirl burner, the configuration of the furnace, and the distribution of the air.

Study on Mixed Coefficient of Pulverized Coal Swirl Burner

TEST STUDY ON OUTLET FLOW FIELD PERFORMANCE FROM WAVE-SHAPED COMBUSTION-STABILIZING BODY OF THE CONCENTRATION TUNABLE RICH/LEAN BURNERS

Study on Flow Field Characteristic of Petal Swirl Burner

Numerical Analysis of the Petal Swirl Burner With Complex Geometry Configuration for Pulverized Coal

Recirculating Structures and Combustion Characteristics in a Reverse-Jet Swirl Pulverized Coal Burner

The Experimental Study On The Flow And Mixing Properties Of The Radial Bias Combustion Swirl Burner

STUDY ON THEORY AND APPLICATION OF PETAL SWIRL BURNER IN LOW BOILER CAPACITY

Combustion Stability of Swirling Burners

Study of the Structural Optimization of a Partially Pre-mixed Type Swirling Burner Burning the Coal Bed Gas With a Low Heat Value

Study on flow fields of centrally fuel rich swirl burner and its applications

Mechanism Analysis on the Pulverized Coal Combustion Flame Stability and NOx Emission in a Swirl Burner with Deep Air Staging

Fourth technology of combustion stability for swirl combustion

Experimental Study on Nox Emission and Unburnt Carbon of A Radial Biased Swirl Burner for Coal Combustion

Experimental Study of the Characteristics of a Novel Swirl Burner for Combustion of Low Rank Pulverized Coal

Gas-Particle Flow and Combustionin the Near-Burner Zone of the Swirl-Stabilized Pulverized Coal Burner

Investigation on Ignition Behaviors of Pulverized Coal Particles in a Tubular Swirl Burner

Flame Interaction and Stabilization Mechanisms in a Dual Premix Swirl Combustor with a Pilot Bluff Body

AN EXPERIMENTAL AND NUMERICAL STUDY ON SWIRLING COMBUSTION PROCESS IN A 200MW PULVERIZED COAL FIRED BOILER

Simulation of Turbulent Multiphase Flow and Pulverized Coal Combustion in Swirl Combustor

Experiment Investigations on the Performance of A Centrally Fuel Rich Swirl Coal Combustion Burner: Influence of Primary Air Ratio

Experimental study on cold two-phase flow in swirl burner exit