Abstract:In this work, carrier-phase direct numerical simulation (CP-DNS) is conducted for a pulverized coal flame in a temporally evolving turbulent jet with flue gas recirculation (FGR). Detailed gas phase kinetics are considered and heavy hydrocarbon molecules up to C20 are included to accurately represent tars in the volatile matter. The structure of the pulverized coal flame is analyzed with different flamelet models considering two mixing scenarios, namely the mixing of recirculated flue gases with the other fuel or oxidizer streams. In the first model approach, the mixing of recirculated flue gases with the gaseous fuels released from the coal particle is characterized with a fuel-split-based flamelet (FLT-FS) model. In the second approach, the mixing of flue gases with the transport air is described with an oxidizer-split-based flamelet (FLT-OS) model. In total, five trajectory variables are introduced in the flamelet table to represent the pulverized coal combustion states with FGR. The suitability of the flamelet models is evaluated through an a priori analysis for both the fully ignited state, as well as (more challenging) the igniting states. Comparisons show that both the FLT-FS model and the FLT-OS model perform well in predicting the thermo-chemical quantities for the fully ignited state. The FLT-OS model performs slightly better than the FLT-FS model in predicting the gas temperature and specific species mass fractions. This is due to the fact that the partial oxidization of the gaseous fuels by the hot flue gases outside the mixing layers cannot be reproduced by the FLT-FS model. While the state at the beginning of ignition can still be accurately predicted by the FLT-OS model, discrepancies can be observed for the tar species C20H10 and the intermediate species CO at a later stage when many particles ignite and the reason for this is explained. Further analysis in the flamelet solution spaces shows that the gaseous fuels are ignited on the fuel-lean side. The time evolution of the gas temperature from the beginning of ignition to the fully ignited state can be overall characterized by both flamelet models.

Study on the reaction kinetics model of pulverized coal combustion based on SCT - Part I: Theory and TGA

Measurements and Modelling of Oxy-Fuel Coal Combustion

A general mechanistic model of fly ash formation during pulverized coal combustion

Correction To: Thermal Analysis and Kinetic Modeling of Pulverized Coal Combustion Accompanied with Coke Breeze

Flame Structure Analysis and Flamelet Modeling of Turbulent Pulverized Solid Fuel Combustion with Flue Gas Recirculation

Kinetic Study on Co-Combustion of Pulverized Anthracite and Bituminite for Blast Furnace Injection

Computational modeling of oxy-coal combustion with intrinsic heterogeneous char reaction models

Optimized TGA-based experimental method for studying intrinsic kinetics of coal char oxidation under moderate or intense low-oxygen dilution oxy-fuel conditions

Experimental and Modeling Investigation of Oxy-Coal Combustion Based on Langmuir-Hinshelwood Kinetics and Direct Calculation of Char Morphology

Modeling of Pulverized Coal Combustion in Turbulent Flow with the Consideration of Intermediate Reactions of Volatile Matter

Thermodynamics of coal oxidation mass gain behavior based on parallel reaction model by TG and DSC

An evaluation of the efficacy of various coal combustion models for predicting char burnout

Comparison and Analysis of Different Models of Pulverized Coal Char Combustion

Discrete Ash Inhibition Model of Char Burning for the CFD Modeling of Precalciner

MODELLING PULVERISED COAL COMBUSTION USING A DETAILED COAL COMBUSTION MODEL

Study on Burning Reaction Kinetics of Coal Coke in Suspension

Kinetics of Coal Char Combustion with Random Pore Model under O2/CO2 Atmosphere

Kinetic Study Of Pulverized Coal Combustion

Numerical analysis of kinetics of char combustion process and selection of mechanism functions

Development of Sulfur Release and Reaction Model for Computational Fluid Dynamics Modeling in Sub-Bituminous Coal Combustion

Study on Characteristics of Coal Chars Combustion in O2/CO2 at High Temperatures Based a Nonlinear Diffusive Model