Abstract:Recent decades have seen a growing concern about ever-increasing green house gas (GHG) emissions and depletion of fossil fuels. Polygeneration, a multi-input multi-output energy system, provides huge opportunities to tackle these problems due to its superior performances over conventional energy systems in terms of energy conversion efficiency and GHG emissions. Many approaches have been made in process design and analysis of polygeneration energy systems, but most of them focus on using coal gasification as the only way to provide gas for downstream utilization. Coke oven gas, another gas source with huge capacity, however, has not received enough attention in polygeneration process design, and researches in this field are still rather limited. In this paper, we present a dual-gas sourced polygeneration process design which uses both gasification gas and coke oven gas and produces methanol, dimethyl ether (DME), and dimethyl carbonate (DMC) in an integrated catalysis procedure. Gasification gas and coke oven gas are converted to synthesis gas, or syngas, via a catalytic reforming procedure, where the ratio between carbon monoxide and hydrogen in the syngas is carefully adjusted according to specific requirements of downstream chemical synthesis reactions. An integrated catalysis procedure follows, where DME is synthesized from the fresh syngas first, unconverted syngas is then sent to a methanol synthesis unit to produce methanol, and part of the methanol is further converted to DMC in a DMC synthesis unit. Based on the proposed process design, an exergoeconomic analysis and an exergy cost distribution diagram are presented, from which the production cost of a product over each functional block of the process can be easily obtained. Analysis results show that the largest exergy loss occurs in an exothermic reformer, accounting 60.4 percent of the total exergy loss. The exergy cost distribution diagram indicates that DMC has the highest exergy cost, followed by DME and methanol, and it is economically favorable to use the exhaust gas from the chemical synthesis block for power generation.

Exergy analysis of a typical polygeneration system

Energy and Exergy Analysis of Poly-Generation System of Hydrogen and Electricity Via Coal Partial Gasification

Exergy Analysis of Methanol-Igcc Polygeneration Technology Based on Coal Gasification

Exergy Analysis of Coal-Based Series Polygeneration Systems for Methanol and Electricity Co-Production

Environmental and exergoeconomic analysis of a low-carbon polygeneration process based on biomass energy, a geothermal source and a high-temperature fuel cell

Advanced Exergy-Based Optimization of a Polygeneration System with CO2 as Working Fluid

Techno-economic evaluation for coal-based polygeneration systems of heat, power, oil and synthetic natural gas

A conceptual hydrogen, heat and power polygeneration system based on biomass gasification, SOFC and waste heat recovery units: Energy, exergy, economic and emergy (4E) assessment

Energy analysis and exergy analysis study of a novel high-efficiency wind-hydrogen storage and power generation polygeneration system

Analysis of energy saving of IGCC-methanol polygeneration systems

Emergy and life cycle assessment of polygeneration system

Decrease of energy demand for bioethanol-based polygeneration system through case study

Performance Assessment of a Novel Polygeneration System Based on the Integration of Waste Plasma Gasification, Tire Pyrolysis, Gas Turbine, Supercritical CO2 Cycle and Organic Rankine Cycle

Proposal of biomass/geothermal hybrid driven poly-generation plant centering cooling, heating, power, and hydrogen production with CO 2 capturing: Design and 3E evaluation

Simulation and exergoeconomic analysis of a dual-gas sourced polygeneration process with integrated methanol/DME/DMC catalytic synthesis

A dual-gas sourced integrated methanol/DME/DMC catalysis approach to polygeneration energy systems design and an exergoeconomic analysis

Thermodynamic and economic analysis of polygeneration system integrating atmospheric pressure coal pyrolysis technology with circulating fluidized bed power plant

Analysis of the Polygeneration System of Methanol and Electricity Based on Coal Gasification (2)

Techno-economic Analysis of Methanol and Electricity Poly-Generation System Based on Coal Partial Gasification

Effect of Methanol Synthesis Ratio on a Polygeneration System

Energy Consumption Performance of Methanol/Electricity Cogeneration Systems