Behavior of desulfurization of dibenzothiophene by corynebacterium sp. ZD-1 in aqueous phase

MiaoDong Wang,Wei Li.,Dahui Wang,Yao Shi

2003-01-01

Abstract:Sulfur emission through fuel combustion is a global problem because it is a major cause of acid rain. Crud oil contains many heterocyclic organic sulfur compounds, among which dibenzothiophene (DBT) and DBTs bearing alkyl substitutions usually are representative compounds. A strain was isolated from refinery sludge and identified as Corynebacterium ZD-1. The behavior of DBT degradation by ZD-1 in aqueous phase was investigated. Corynebacterium ZD-1 could metabolize DBT to 2-hydroxybiphenyl (2-HBP) as the dead-end metabolite through a sulfur-specific pathway. In shake flask culture, ZD-1 had its maximal desulfurization activity in the late exponential growth phase and the specific production rate of 2-HBP was about 0.14 (mmol kg dry cell min(-1)). Active resting cells for desulfurization should be prepared only in this period. The growth of strain ZD-1, the production of DBT degradation enzymes and the enzymes' activity were all inhibited by 2-HBP. Sulfate inhibited the production of dibenzothiophene (DBT) degradation enzymes but had no effect on the enzymes' activity. It was difficult to measure the DBT concentration accurately at high cell densities, therefore, the activity of the resting cells should be expressed as 2-HBP production rather than DBT degradation. The production rates of 2-HBP at lower cell densities were higher and the maximum conversion amount of DBT to 2-HBP (0.067 mmol(.)L(-1)) after 8 h was gained at 9.2 (g dry cell(.)L(-1)) rather higher cell density. This was probably due to the mass transfer limitation, specially oxygen transfer needed for the oxidation reaction of DBT. The good activity of desulfurization and the sulfur-specific (4S) pathway for Corynebacterium ZD-1 indicate that this newly isolated strain could be a promising biocatalyst for DBT desulfurization.