Abstract:Severe slugging, which could induce large-amplitude pressure and flow rate fluctuations, is a major and expensive problem in multiphase transportation systems of offshore oil production system. To avoid such problem is a basic requirement for flow assurance management. This study is an experimental and numerical investigation of severe slugging in a relatively long pipeline-riser system. A series of experiments on two-phase, air-water flow in a flexible S-shaped riser were carried out. The experimental system has a 114m long horizontal pipeline connected to a 19m long pipe which is inclined to -2degree from horizontal, followed by a 15.3m high riser operating at atmospheric end pressure. Four types of flow patterns were found and characterized by the pressure fluctuations at the bottom of the riser. A flow patter map for the prediction of severe slugging was developed based on the experimental results. The detailed characteristics of severe slugging such as pressure fluctuations, liquid holdup, under different gas-liquid superficial velocities were provided. A transient model to predict the flow behavior in the pipeline-S-shaped riser system was developed based on an existing model (OLGA). The modified model, which was tested against new experimental results obtained in this study, showed that the four types of flow patterns observed in the experiment were predicted with acceptable discrepancies. The flow pattern map was obtained using present model, as well as the detailed characteristics of severe slugging. in addition, the reasons for the difference between experimental and numerical results were analysed in this article. The motive of the numerical studies was to identify the areas that could not be reproduced by the present model and to give some suggestions for future models.

Experimental Investigation of the Slug Flow Operation Characteristics

An Experimental Study of the Flowrate Transients in Slug Flow

PIV Experimental Research and Numerical Simulation of the Pigging Process

Experimental research on the contact force of the bi-directional pig in oil and gas pipeline

Experimental study of the flowrate transients

Experimental study on controllable pseudo-slug flow characteristics in horizontal pipe

Experimental Investigation on Long Hydrodynamic Slugs in Offshore Pipeline

Experimental Investigation of Slug Development on Horizontal Two-phase Flow

EXPERIMENTAL STUDY ON MEASURING CHARACTERISTICS OF SLUG FLOW IN HORIZONTAL PIPE

Numerical Investigation on Pressure and Liquid Hold up of Severe Slugging

Flow Characteristics of Stable Oil-Gas Two-Phase Slug Flow in Horizontal Pipe

Investigations of the Formation Mechanism and Pressure Pulsation Characteristics of Pipeline Gas-Liquid Slug Flows

Experimental Investigation on Mitigation of Severe Slugging in Pipeline-Riser System by Quasi-Plane Helical Pipe Device

Effects of a Long Pipeline on Severe Slugging in an S-shaped Riser

MEASUREMENT OF SLUG VELOCITY AND LENGTH IN HORIZONTAL PIPELINE BY MEANS OF DIFFERENTIAL PRESSURE FLUCTUATION ANALYSIS

Non-uniformity of Gas/liquid Flow in a Riser and Impact of Operation and Pipe Configuration on Slugging Characteristics

Experimental Study of Severe Hydrodynamic Slugging in a Gas-Liquid Pipeline-Riser System

Experimental investigation on characteristic parameters of air–water slug flow in a vertical tube

Development of Liquid Slug Length in Gas-Liquid Slug Flow along Horizontal Pipeline: Experiment and Simulation

Experimental and Computational Investigations on Severe Slugging in A Catenary Riser

Severe slugging in a flexible S-shaped riser system: Experimental studies and transient simulation