Abstract:Many fire accidents of electric vehicles were reported that happened during the charging process. In order to investigate the reasons that lead to this problem, this paper studies the thermal safety of Li-ion batteries under limited overcharge abuse. A 3D electrochemical-thermal coupled model is developed for modeling thermal and electrochemical characteristics from normal charge to early overcharge state. This model is validated by experiment at charge rates of 0.5C, 1C, and 2C. The simulation results indicate that irreversible heat contributes most to temperature rise during the normal charge process, but the heat induced by Mn dissolution and Li deposition gradually dominates heat generation in the early overcharge period. Based on this, a threshold selection method for multistage warning of batteries overcharge is proposed. Among them, level 1 should be considered as a critical stage during the early overcharge process due to the deposited lithium starts to react with electrolyte at the end of level 1, where temperature rate increases to 0.5 degrees C min(-1) for 1C charge. While the thresholds of levels depend on charge rate and composition of battery. Furthermore, several critical parameters are analyzed to figure out their effects on thermal safety. It is found that the temperature at the end of overcharge is significantly influenced by the change of positive electrode thickness and solid electrolyte interface (SEI) film resistance. The final temperature increases by 17.5 degrees C and 7.9 degrees C, respectively, with positive electrode thickness ranging from 50 to 80 mu m and SEI film resistance increasing from 0.002 to 0.03 omega.

Overcharging Protection and Temperature Compensation of Lead Acid Battery

STUDY ON OVERCHARGING PROTECTION AND TEMPERATURE COMPENSATION OF VRLA BATTERY IN RENEWABLE ENERGY SYSTEM

Research on Overcharge and Overdischarge Effect on Lithium-Ion Batteries

Comprehensive Investigation of a Slight Overcharge on Degradation and Thermal Runaway Behavior of Lithium-Ion Batteries

Progress of overcharge performance improvement for Li-ion batteries

A Comparative Study on the Degradation Behaviors of Overcharged Lithium‐ion Batteries under Different Ambient Temperatures

Thermal Safety Study of Li‐ion Batteries under Limited Overcharge Abuse Based on Coupled Electrochemical‐thermal Model

Analysis of the Thermal Stability of a Battery under Overcharge and Over-Discharge

Influence of the charge regulator strategy on state of charge and lifetime of VRLA battery in household photovoltaic systems

Temperature mitigation effect of phase change material on overcharging lithium-ion batteries: an experimental study

Quantitative Analysis of Aging and Detection of Commercial 18650 Lithium-Ion Battery under Slight Overcharging Cycling

Heat generation and thermal runaway mechanisms induced by overcharging of aged lithium-ion battery

The Influence of Carbon Material on the Low-Temperature Performance of Lead-Acid Battery

Thermal behavior and failure mechanisms of 18650 lithium ion battery induced by overcharging cycling

Comparison of the Overcharge Behaviors of Lithium-ion Batteries under Different Test Conditions

Overcharge Investigations of LiCoO2/Graphite Lithium Ion Batteries with Different Electrolytes

Investigation on the root cause of the decreased performances in the overcharged lithium iron phosphate battery

Electrolyte Additives for Improving the High-Temperature Storage Performance of Li-Ion Battery NCM523∥Graphite with Overcharge Protection.

Failure mechanism of Li-ion battery at overcharge conditions

Dynamic overcharge investigations of lithium ion batteries with different state of health

Research on the on-line maintenance technology of the battery for communication power supply