Abstract:High quality NaA zeolite membrane was synthesized on an α-Al2O3 support with the aid of nucleation seeds from a gel synthesis mixture. The influence of synthesis conditions, such as synthesis times, synthesis stages and nucleation seeds, on the formation and permeation properties of the NaA zeolite membranes was investigated. Nucleation seeds played a critical role on the formation of a continuous NaA zeolite membrane on the support surface. The quality of the NaA zeolite membranes were improved by employing the multi-stage synthesis method. The best NaA zeolite membrane was obtained after a three-stage synthesis with the synthesis time of 24h and with the aid of nucleation seeds.Single gas permeation properties of the NaA zeolite membranes were studied. The permeance of H2, O2, N2 and n-C4H10 decreased as the molecular kinetic diameter of the gases increased. At 298K and under pressure difference of 0.10MPa, the permselectivity of H2/N2, H2/n-C4H10 and O2/N2 were 20.1, 106 and 2.61, respectively, which were much higher than those of the corresponding Knudsen diffusion ratios of 3.74, 5.39 and 0.96. With increasing temperature, the gas permeance increased and the permselectivity of H2/N2, H2/n-C4H10 and O2/N2 slightly decreased. All these properties indicated that the gases mainly permeated through the channels of NaA zeolite and the gas permeation was predominantly controlled by the molecular sieving effect of NaA zeolite membrane. However, the permeation of n-C4H10 indicated that the NaA zeolite membranes had certain defects with diameters larger than the pore size of NaA zeolite.

Dense A-Type Zeolite Membrane Synthesized by Seeding

SYNTHESIS AND CHARACTERIZATION OF A-TYPE ZEOLITE MEMBRANES ON ALUMINA PARTICLES SURFACE

Preparation of Asymmetric Zeolite NaA Membrane Layers by Vapor Phase Transfer and Seeded Growth Method

Preparation of Zeolite NaA Membranes on Macroporous Alumina Supports by Secondary Growth of Gel Layers

Synthesis and properties of A-type zeolite membranes by secondary growth method with vacuum seeding

Preparation of high-performance zeolite NaA membranes in clear solution by adding SiO2 into Al2O3 hollow-fiber precursor

Enlarged Area A-type Zeolite Membranes Prepared by Vacuum Seeding Method

Synthesis of Naa Zeolite Membrane on Seeded Substrate and Its Characterization

Synthesis of NaA zeolite membranes from clear solution

Preparation of zeolite MFI membranes on alumina hollow fibers with high flux for pervaporation

Preparation of NaA Zeolite Membrane on Macroporous α-Al2O3 Support by Two-Step-Seeding Method

Seed-Free Synthesis of Highly Permeable Zeolite Naa Membranes Through Deposition of Aptes-Functionalized Alumina Particles on Macroporous Supports

A Facile Preparation of High Flux NaA Zeolite Membranes by Direct Secondary Growth of Wet Gel Layer

Novel two-layered zeolite NaA-silicalite-1 membranes

Influences of Seeds on the Properties of Zeolite NaA Membranes on Alumina Hollow Fibers

Ultrasonic-assisted Fabrication of High Flux T-type Zeolite Membranes on Alumina Hollow Fibers

The preparation of zeolite NaA membranes on the inner surface of hollow fiber supports

Preparation of NaA zeolite membranes on macroporous supports by the varying-temperature spraying seeding method

Manipulation of the Surface Microstructure and Its Effects on the Flux of NaA Zeolite Membranes in Pervaporation

Fabrication of Zeolite Naa Membranes on Hollow Fibers Using Nano-Sized Seeds Exfoliated from Mesoporous Zeolite Crystals

Synthesis; Characterization and Single Gas Permeation Properties of NaA Zeolite Membrane