Abstract:The sintering and microwave dielectric properties of a ceramic material based on the mixing of Mg3B2O6 and Zn3B2O6 have been widely studied using first principles calculations and experimental solid‐state reactions. Characterization methods include the Network Analyzer, X‐ray, Raman diffraction, scanning electron microscopy, energy‐dispersive spectroscopy, and differential‐thermal & thermo‐mechanical analyzer. The increasing amount of Mg2+ results in the appearance of Mg2B2O5 and ZnO, and the mutual substitution (Mg2+ and Zn2+) phenomenon has emerged in Zn3B2O6 and Mg2B2O5. The mechanisms have been explained with the help of DFT calculations. The bond parameters and electron distributions of the ZnO4 tetrahedron and the MgO6 octahedron have been modified due to substitution. The sintering, substitution, and phase formation properties have been analyzed quantitatively through the energy parameters. The best dielectric properties were obtained for x=0.20 sintered at 950 ℃, εr=6.47, Q×f=89,600 GHz (15.2 GHz), τf=‐48.6 ppm/℃, relative density=96.7 %. The mixing of Zn3B2O6 and Mg3B2O6 ceramics is a feasible method to obtain a ceramic with low sintering temperature and excellent dielectric properties.

Preparation of B2O3-P2O5-SiO2 glass-ceramics by the sol-gel method

Low Dielectric Constant Borophosphosilicate Glass–ceramics Derived from Sol–gel Process

Low Dielectric Constant Borophosphosilicate Glass-Ceramics Doped with Pbf2

Low Dielectric Constant Borophosphosilicate Glass-Ceramics: Synthesis and Properties

Low Dielectric Constant B2o3-P2o5-Sio2 Ceramics Derived From Mixed-Solid Process

Synthesis and dielectric properties of Ba<sub>2</sub>TiSi<sub>2</sub>O<sub>8</sub> glass-ceramics from the sol–gel process

Synthesis and dielectric properties of Ba 2 TiSi 2 O 8 glass-ceramics from the sol–gel process

Preparation of Ti Doped BaFe12O19 Ceramics by a Sol-Gel Process

Effect of SiO2/BaO ratio on sintering behavior, crystallization behavior, and properties of SrO–BaO–B2O3–SiO2 glass-ceramics

Formation of sol-gel in situ derived BTO/NZFO composite ceramics with considerable dielectric and magnetic properties

Low Dielectric Constant Ceramics of ZnO-Li2O-B2O3-SiO2 System prepared by Mixed-Solid Process

Studies on low-temperature preparation and microwave properties of BaFe12O19 / SiO2-B2O3-K2O microcrystallite glass ceramics

Preparation And Properties Of Ba2znzco2-Zfe12o22-Sio2 Microcrystallite Glass Ceramics By Citrate Sol-Gel Process

Low dielectric and high frequency glass-ceramic in the system CaO-B2O3-SiO2

Effects of B2O3 content on crystallization behavior and properties of low temperature co-fired CaO-B2O3-SiO2 glass-ceramics

Research on Low-temperature Sintering of Boracic Silicate Glass

MgO-Al<sub>2</sub>O<sub>3</sub>-SiO<sub>2</sub> Glass-Ceramic Prepared by Sol-Gel Method

Studies on preparation and microwave properties of BaFe12O19/SiO2 - Microcrystallite glass ceramics by citrate sol-gel process

Densification and Dielectric Properties of CaO–B2O3–SiO2 System Glass Ceramics

Three‐phase borate solid solution with low sintering temperature, high‐quality factor, and low dielectric constant