Abstract:The growth of high-quality ZnO bulk crystals is an outstanding challenge, and the nature of grown-in defects in crystals is far from well understood. In this work, a specially designed low-temperature-gradient CVT growth system was developed based on finite element analysis. High-quality ZnO single crystals were successfully grown. The supersaturation front in the growth system was controlled, and internal stress in the crystal was reduced by introducing a radiation baffle and a special seed pedestal. The structural, electrical, and optical properties of ZnO crystals were studied before and after oxygen annealing. The scanning electron microscope (SEM) and optical microscope (OM) results indicate the stable growth is achieved under the Zn-rich growth condition. The X-ray rocking curve measurements reveal the high crystalline quality of the grown crystal with the full-width at half-maximum (FWHM) value of 17 arcsec for the (004) reflection. The time-of-flight secondary ion mass spectroscopy (ToF-SIMS) results prove the high purity of grown crystals and reveal the variations of trace impurity concentrations in crystals. When annealed in oxygen at 1000 °C, the optical band gap (Eg) changes from 2.50 eV to 3.15 eV. The Raman analysis indicates that oxygen vacancies (Vo) in the as-grown crystal disappear after annealing. The Hall measurements show that the room temperature (RT) mobilities before and after annealing are 197 cm2V−1c−1 and 207 cm2V−1c−1, respectively. The RT carrier concentration decreases by about two orders of magnitude to 5.45 × 1015 cm−3, while the RT resistivity increases by about one order of magnitude to 5.57 Ω cm after annealing. The positron annihilation lifetimes (PALS) results prove the presence of Zn vacancies (Vzn) after annealing. The origins of as-grown ZnO green luminescence (GL) and the temperature-dependent blue shifts of the GL peak positions are explained based on Zni and Vo defects. The fine structures of annealed ZnO GL are found to be related to Vzn native defects rather than Cu impurity.

Nucleation and growth process of the needle-like goethite crystals

A Study of the Morphology of the Goethite Crystallization Process

Nucleation on Thermal History and Microstructural Evolution of Atomized Ti-48Al Nano and Micro-Powders

The Characterization And Preparation Of Nano-Scale Fe Doping Tio2 By Sol-Gel Method - (Ii) - The Crystal Character And Grain Growth Of Fe Doping Tio2 Xerogel Powders

Simple Approaches To Quality Large-Scale Tungsten Oxide Nanoneedles

Thermal History Effect on the Nucleation of Oxygen Precipitates in Germanium Doped Cz-silicon Studied by High-Energy X-ray Diffraction

Reaction Kinetics of Shearing-Enhanced Goethite Process for Iron Removal from Zinc Solution

Influence of Preparation Conditions on Synthetic Goethite

Controllable growth of dendrite-like CuO nanostructures by ethylene glycol assisted hydrothermal process

The Crystal Growth Habits and Nucleation Mechanism of Hydrothermal Crystallization of Nano-AlOOH

Goethite and Hematite Nucleation and Growth from Ferrihydrite: Effects of Oxyanion Surface Complexes

Synthesis and Characterization of Needle‐Like ZnO by Gemini Surfactant‐Assisted Hydrothermal Process

Anisotropic Growth and Formation Mechanism Investigation of 1d Zno Nanorods in Spin-Coating Sol-Gel Process

Single Crystal Growth Via a Grain Rotation Mechanism Within Amorphous Matrix

Nanocrystal Growth on Graphene with Various Degrees of Oxidation

Particle stimulated nucleation of recrystallization in 01420 Al-Li alloy

Oxidation Growth Micromechanism of ZnO Nanoparticles at Low Temperature

Growth and Properties of Single-Crystalline Γ-Fe2o3 Nanowires

[The Study on the Growth Process of ZnO Nanorods].

Crystal growth, finite element analysis and oxygen annealing of ZnO bulk crystal grown by low-temperature-gradient chemical vapor transport

Growth Mechanism of Zno Nanocrystals with Zn-Rich from Dots to Rods