Abstract:In this paper a full bridge isolated DC-DC converter is proposed where the active switches are zero-current-switched (ZCS) for the entire range of operation. The proposed converter is targeted for high voltage, high power applications where input side bridge employs insulated gate bipolar field effect transistors (IGBT) and zero voltage turn OFF (ZVS) cannot be fully realised due to the tail current of the IGBT. The input side bridge has three half-bridge legs followed by two high frequency transformers. The Net output of the transformers is fed to a diode bridge feeding a resistive load through a LC filter. In contrast to the conventional phase shifted full bridge converter (PSFB), during the zero state (when there is no active power transfer from input to output), current does not circulate in the input bridge as well as in the transformers. Also the converter has low duty cycle loss. Thus the converter is suitable for the applications with wide output voltage variation as well. The proposed circuit also ensures soft commutation of the diode bridge rectifier. The converter operation principle is discussed. A 1.5 kW prototype is built and tested. Key experimental results are presented to verify the operation.

High power high frequency zero current transition full bridge DC/DC converter

An Improved Three-Level Soft-Switching DC/DC Converter

A Zero-Voltage Zero-Current Soft Switching DC/DC Converter

Research on the Current-fed Phase Shift Full Bridge DC/DC Converter

Single-Phase Single-Stage Isolated ZCS Current-Fed Full-Bridge Converter for High-Power AC/DC Applications

A Novel Zero-Current-transition Full Bridge DC/DC Converter

High Power High Frequency Half-Wave-mode ZCT-PWM Full Bridge DC/DC Converter

A ZCS AC/DC CONVERTER WITH HIGH POWER FACTOR BASED ON PWM CONTROL STRATEGY

Soft-Switching Single-Stage Current-Fed Full-Bridge Isolated Converter for High Power Ac/Dc Applications

A Zero-Current Switching (Zcs) Current Source Converter For High-Frequency Pwm Applications

Zero Voltage Dual-LLC Resonant Soft Switching Converter for Super High Frequency Induction Heating Power Supplies

Design and experiment of a zero-voltage-switching module for bidirectional DC solid-state transformer

A Novel Zero-Current-transition Three-Level DC/DC Converter

Current-Feed Single-Switch Forward Resonant DC Transformer (DCX) with Secondary Diode-Clamping.

An Improved ZCT-Boost DC/DC Converter for High Power Applications

A Soft-Switching Full-Bridge Inverter with High Efficiency

A Novel ZVS DC/DC Converter for High Power Applications

Modeling, Analysis and Design of 15kw Zero-Voltage Zero-Current Switched Full Bridge PWM Converter

A Zero-Current-Switched PWM Full Bridge DC-DC Converter

The three-level ZVS-PWM DC-to-DC converter

Analysis and Design of Zero-Voltage-Switching Multiphase AC/DC Converters