Abstract:Heavy oil coking is an important process for in situ combustion. The coking characteristics of two low-asphaltene heavy oils from Fengcheng (FC) and Hongqian (HQ) oilfields, which are different in viscosity, density, and composition, were studied in a fixed bed reaction system in pyrolysis and oxidizing atmospheres. FC heavy oil showed a 35% higher coke yield than HQ heavy oil, and the coke oxidation activity was worse, whereas the coke elemental compositions and heat values were similar for both cokes. Kinetic analysis of coke oxidation showed that both cokes from FC and HQ oils had similar activation energies, 124 kJ/mol for cokes from oil pyrolysis and 138 kJ/mol for cokes from oil oxidation, but their active site numbers are different. The coking characteristics of two oils' main fractions (saturates, aromatics, and resins) were studied and compared. In the inert atmosphere, the main coking fraction was resins with a coke yield of 17%, whereas all three fractions produced coke in the oxidizing atmosphere. The coke yields of saturates, aromatics and resins were around 7%, 25% and 57% in oxidizing atmosphere, respectively. There was a small difference in the coke yields of the same fraction from the two heavy oils. Saturates and aromatics from the FC heavy oil showed a 20-30% higher coke yield than the same fractions from HQ oil because of the different contents of low-boiling-point components. After removing the influence of low-boiling-point components, the coke yield of the heavy oil could be predicted by a weighted average method based on the main fraction contents and their coke yields. Upon comparing the coke produced by different fractions, the coke from saturates showed better oxidation activity than that from aromatics and resins. The oxidation activities of coke produced by FC aromatics, HQ aromatics, and HQ resins were similar, but that of coke produced by the FC resins was worse. FC oil coke was less reactive than HQ oil coke probably due to the high resin content of FC heavy oil and the low oxidation activity of the coke from its resins.

Effect on coking behaviour of a special petroleum pitch by the addition of LDOHF oligomers

Effects of Aluminoxane Cocatalysts on Bis(imino)pyridine Iron‐catalyzed Ethylene Oligomerization

Insight into the reactivity of aromatic-rich fractions co‐carbonized with polyethylene glycol for preparation of isotropic pitch with superior spinnability

Effect of petroleum-based coating pitch preparation on toluene insolubles generation

Liquefaction of Hongliulin coal asphaltenes and conversion of oxygenic structure

Effective Preparation of Mesophase by Segmented Hydrogenation/Thermal Polycondensation of Coal Liquefied Pitch

Insight into low-temperature co-pyrolysis of Qinglongshan lean coal with organic matter in Huadian oil shale

Comparative Study on the Coking Characteristics of Two Low-Asphaltene Heavy Oils and Their Main Fractions

Hydrogenation Behaviors and Structural Variations of Subfraction of Coal Tar Pitch and Preparation of Mesophases with Well-Developed Optical Textures

Comparative investigation of low temperature oxidized and pyrolyzed cokes from the inferior heavy oil: Structural feather, thermo-oxidation behavior, and kinetics

Co-Pyrolysis Behaviors of the Cotton Straw/PP Mixtures and Catalysis Hydrodeoxygenation of Co-Pyrolysis Products over Ni-Mo/Al2O3 Catalyst

Evaluating of the oxidative behaviors of isotropic pitch fractions for optimal the mechanical properties of isotropic pitch-based carbon fibers

Effect of Extracted Compositions of Liquefaction Residue on the Structure and Properties of the Formed-coke

Co-carbonization Behaviors of Petroleum Pitch/waste SBS: Influence on Morphology and Structure of Resultant Cokes

The Effect of Boron Trifluoride Complex on the Preparation of Mesophase Pitch from FCC Decant Oil Fractions with Different Compositions and Molecular Structures

Study on structures and properties of isotropic pitches and carbon fibers from co-carbonization of aromatic-rich distillate oil and polyethylene glycol

Preparation of pitch semi-coke water slurry and its properties of slurryability and gasification

An Investigation of the Preparation of Coal Tar- and Petroleum-Based Pitch Spheres and Their Oxidation Stabilization

Effect of Decomposition of Oxygen-Containing Structures on the Conversion of Lignite in the Presence of Hydrogen Donor Solvent

Studies on mesophase transformation behavior of naphthalene oligomers prepared using ZrO2/SO4 2- catalyst

Effects of endothermic hydrocarbon fuel composition on the pyrolysis and anti-coking performance under supercritical conditions