Abstract:The traditional dynamometers consume more fuel or electric energy while working, so they not only waste energy, but also have lower dynamic performance. An AC variable-frequency power dynamometer scheme is presented based on PWM rectifier and fuzzy direct torque control (DTC) of induction motor in this paper. The dynamometer can operate in both motoring and generating states. The bidirectional flow of the energy with unit power factor between the power grids and the dynamometer is realized by voltage-oriented control (VOC) three-phase PWM rectifier. The dynamometer absorbs the energy from the power grids in motoring state, and feeds back the energy generated by the dynamometer to the power grids in generating state. In order to improve dynamic response capability and decrease the torque ripple of the dynamometer, the fuzzy logic idea is adopted based on conventional DTC. The stator flux angle, the stator flux error, and the torque error are reasonably fuzzified into several fuzzy subsets to optimize selection of the voltage vector. The proposed scheme is implemented with a single board microcomputer that uses TMS320LF2407A DSP and intelligent power model (IPM) to validate its feasibility. Experimental results show that the dynamometer has outstanding dynamic and static performance. The application of this novel dynamometer both saves the energy source and decreases the disturbances to power grids caused by rectification

A Study on the Control System of AC Dynamometer

Study on the Control of AC Dynamometer System for Hybrid Electrical Vehicle Test Bench

Development of the Control and Acquisition System for a Natural-Gas Spark-Ignition Engine Test Bench

Control method of multi-motor's speed synchronization control in dynamometer test bench for multi-axles'vehicle

The Development of the AC Dynamometer System Based on PXI

Study of Control Algorithm of Dynamometer Controller

Research on a Novel AC Variable-Frequency Dynamic Power Dynamometer

Control and implementation of alternating current variable-frequency power dynamometer

Research on an AC Variable-frequency Power Dynamometer Based on PWM Rectifier and Fuzzy Direct Torque Control

Automatic Control System for a Torque Converter Static and Cycle Hydraulic Tester

Development of AC Dynamometer Controller Based on VI Architecture

A Novel Dynamic Power Dynamometer Based on PWM Rectifier and Direct Torque Control of Induction Machine

Research on an energy feedback power dynamometer based on improved vector control

Measuring and Controlling System of the Accelerated Bearing Life Tester with Auto-loading

Study of Automatic Dynamic Balancing System for Engine Crankshaft

Study of Control Algorithm of Eddy Current Dynamometer Controller under N/m Mode

Analysis Study of Instable Points in the Eddy Current Dynamometer and the Engine System at Low Rotate Speed

Study on AC Dynamometer Control System Based on CANopen Protocol

Development of the Controller for Eddy Current Dynamometer Based on PWM Control

Permanent Magnet Synchronous Motor Control System Based on No Manual Tuned Active Disturbance Rejection Control

MAP Learning and Disturbance Observation Based Engine Torque Control for Dynamometer Test Bench