Abstract:Numerical simulation is performed in the present study to get further insight into the mechanism of heat transfer phenomena of water in ∅32×3mm horizontal smooth tubes under supercritical pressures. Both the heat transfer enhancement (HTE) and heat transfer deterioration (HTD) in the so-called large specific heat region (LSHR) of supercritical fluids are analyzed based on the numerical results. The governing equations of the fluid are solved on fixed three-dimensional grid systems, and the RNG-k–ε model with enhanced wall treatment method is employed to handle the coupled wall-to-fluid heat transfer. The numerical results are compared with the corresponding experimental data, and a good agreement is achieved, indicating good accuracy and reliability of the numerical method used in this study. Variation of the tube inner wall temperature and the local heat transfer coefficient with a few parameters, such as the local water enthalpy, the water mass flow rate and the heat flux on the tube wall, are obtained under various conditions. It is showed that in the large specific heat region (LSHR), there exists strong non-uniformity in the circumferential distribution of the tube inner wall temperature, and as well, the heat flux on the inner tube wall are distinctly non-uniform along the tube wall circumference. Further analysis of the numerical data shows that the above-mentioned non-uniformity is mainly due to the rapid change in fluid properties, which results complex secondary flows and mixed convection in the supercritical fluid. Based on the numerical results, a critical value is obtained for the parameter Gr/Re2.7, which is believed to be a key parameter affecting the secondary flow in the LSHR. In the present study, the critical value for Gr/Re2.7 is determined to be 1.5×10−5, above which the HTD phenomenon may be observed.

Numerical Study on Free Convection Heat Transfer From Sphere Particle in Supercritical Water

Numerical Study on the Mixed Convection Heat Transfer between a Sphere Particle and High Pressure Water in Pseudocritical Zone

NUMERICAL STUDY ON LAMINAR FREE CONVECTION HEAT TRANSFER BETWEEN SPHERE PARTICLE AND HIGH PRESSURE WATER IN PSEUDO-CRITICAL ZONE

Mixed Convection Heat Transfer from a Particle in Supercritical Water

Supercritical Water Flow Over a Spherical Particle

Influence of Special Water Properties Variation on the Heat Transfer of Supercritical Water Flow Around a Sphere

Numerical Investigation on the Heat Transfer of Particle Arrays in Supercritical Water

Numerical Investigation on the Drag Characteristics of Supercritical Water Flow Past a Sphere

Numerical Investigation of Heat Transfer Characteristics Between Two Particles and Supercritical Water

Numerical Investigation of the Effect of Surface Roughness on Flow and Heat Transfer Characteristics of Single Sphere Particle in Supercritical Water

Numerical Simulation of Adiabatic/cooled/heated Spherical Particles with Stefan Flow in Supercritical Water

Fluidization in Supercritical Water: Heat Transfer between Particle and Supercritical Water

Numerical Research on Heat Transfer Characteristics Analysis of Two Particles in Supercritical Water

Numerical Investigation on the Mixed Convection and Heat Transfer of Supercritical Water in Horizontal Tubes in the Large Specific Heat Region

Numerical Simulation and Comparison of Turbulent Heat Transfer in Supercritical and Subcritical Water

Numerical Simulation on Natural Convection and Heat Transfer of Supercritical Water in a Side-wall Heated Cylinder

Numerical Investigation of Flow and Heat Transfer of Supercritical Water in the Water-Cooled Wall Tube

Numerical Analysis on Supercritical Water Heat Transfer in a 2 × 2 Rod Bundle

Numerical Analysis on Heat Transfer Characteristics and Buoyancy Effects of Supercritical Pressure Water in Vertical Tube

Large Eddy Simulation on Heat Transfer Characteristics of Supercritical Water in Double-Pipe Heat Exchanger

Numerical Investigation of Supercritical Water Turbulent Flow and Heat Transfer Characteristics in Vertical Helical Tubes