Abstract:The present work investigated the effects of magnetic field annealing on the magnetic properties, mechanical properties and microstructure of the Fe80Si9B11 amorphous alloys. The results show that the soft magnetic properties (SMPs) were obviously improved after the samples were annealed below the crystallization temperature with a 1 T magnetic field. The atom probe tomography (APT) results showed that the magnetic field has little effect on the element distribution of the annealed samples at 653 K. The results of XRD and TEM showed that the 653 K x 0 T sample included a few nanocrystals and an amorphous matrix while the 653 K x 1 T sample still retained an amorphous structure. It is worth noting that a large number of spherical symmetry clusters and a small number of translational symmetry clusters can be observed in the 653 K x 1 T sample. Many translational symmetry clusters, and a few spherical symmetry clusters, can be identified in the 693 K x 1 T sample. Both good soft magnetic properties (SMPs) and acceptable mechanical properties were obtained after the sample was annealed at 653 K. Compared with that of the as-cast sample, the values of maximum magnetic flux intensity (B-m), elastic modulus (E-r) and hardness increased by 13.7%, 36.6% and 9.4%, respectively, while the values of coercivity (H-c) and hysteresis loss (P-u) decreased by 71.5% and 68.2%, respectively. After the sample was annealed at 693 K, the SMPs exhibited a deterioration, and Er and hardness also dropped sharply. Based on the above results, the mechanism of the microstructural change for Fe80Si9B11 amorphous alloys related to the magnetic field annealing conditions was proposed. The relationship between the soft magnetic properties, mechanical properties, and the microstructure of the sample was also discussed. This paper provides a basis for the further improvement the SMPs of the Fe80Si9B11 amorphous ribbons by controlling the microstructure.

Effects of Magnetic-Field Annealing on the Morphology and Magnetic Properties of La 0.7 Sr 0.3 MnO 3 Film

Effect of Thermal-Annealing on the Magnetoresistance of Manganite-Based Junctions

Research on the enhanced magnetoresistive response in magnetic-annealed La0.7Sr0.3MnO3

The Effect of Annealing on Magnetic and Transport Properties of La0.5sr0.5coo3-Delta Thin Films

The Effect of Annealing Temperatures on the Microstructure of La0.5ca0.5mno3 Films

The Transport Properties of La0.8zr0.2mno3 Film

Mn and Mg Interdiffusion and Magnetotransport Properties of La0.7sr0.3mno3 Films on Mgo (100) Substrate

Effect of Annealing Ambient on the Ferromagnetism of Mn-Doped Anatase Tio2 Films

Annealing Effect on the Electronic Structure and Magnetic Properties of Mn-doped ZnO Films

Enhancing Low-Field Magnetoresistance of La 0.67 Ca 0.33 MnO 3 Films Deposited on Anodized Aluminium-Oxide Membranes

Evolution of electrical and magnetotransport properties with lattice strain in La0.7Sr0.3MnO3 film

Effects of Annealing Conditions on the Microstructure and Magnetic Properties of the Perovskite Manganite, La0.75Sr0.25MnO3

The Effect of the Deposition Temperature on the Lowfield Magnetoresistance of Polycrystalline La 0 . 5 Sr 0 . 5 MnO 3 Thin Films Produced by Pulsed Laser Deposition

Effects of annealing and strain on La_{1-x}Ca_{x}MnO_{3} thin films: a new phase diagram in the ferromagnetic region

Partially Crystallized La0.5sr0.5mno3 Thin Films by Laser Ablation and Their Enhanced Low-Field Magnetoresistance

Low-field Magneto-Transport Property of La0.5Sr0.5MnO3 Thin Films Deposited at Low Temperature by Laser Ablation

Film Orientation Effects on the Structural, Magnetic and Transport Properties of LaMnOy Thin Films

Substrate-dependent Post-Annealing Effects on the Strain State and Electrical Transport of Epitaxial La5/8-yPryCa3/8MnO3 Films

Strain Effects and Phase Separation Tendency in Highly Strained La0.7Ba0.3MnO3 Thin Films on LaAlO3 Substrates

The Effects of Magnetic Field Annealing on the Magnetic Properties and Microstructure of Fe 80 Si 9 B 11 Amorphous Alloys

Low-field Magnetoresistive Property of Partially Crystallized La0.5Sr0.5MnO3 Thin Films by Pulsed Laser Deposition