Abstract:Thermal control device based on thermochromis plays an important role in spacecrafts thermal management by automatically adjusting its radiative properities in response to large temperature gradients. The thermal management ability was determined by the device surface radiation performance. During the sun shadow, it is required to dissipate heat as little as possible from spacecraft, which is a low emittance device. While, it desired the device emittance is large enough to meet the heat dissipation requirement facing with the direct sunlight. As a type thermochromic material, La1 - x Sr x MnO3 (LSMO) has obtained broad attention because it showed a considerable superiority in saving energy consumption in space thermal management. It can hold the heat at low temperature due to its low emittance behavior, whereas dissipate the excess heat at high temperature for its high emittance properties. In this work, we prepared the La1 - x Sr x MnO3 ( x= 0125, 0.175, and 0.2) nanoparticles by sol-gel method from the precursors such as lanthanum nitrate hexahydrate, strontium nitrate and manganese nitrate solution (50%). LSMO nanoparticles were dispersed homogeneously in a solution of resins. The mixture then was spin-coated on the clean Al substrates. After standing for 10 h, the coating was cured at 120°C. The structure, morphology, and composition analysis of LSMO nanoparticles or coatings were investigated by X-ray diffraction technique, scanning electron microscopy, and the energy dispersive X-ray spectroscopy, respectively. The total hemispherical emittance of coating was measured by calortmetric method, which test sample was suspended in the center of a liquid nitrogen thermostat. According to the input power, sample temperature, and thermostat temperature, the emittance can be indirectly obtained. Two resins, which is the acrylic resin and the solution of terpineol and ethyl cellulose respectively, was considered to investigated the effect of reslin type on the emittance of coatings. The result of X-ray diffraction shows a single perovskite structure for LSMO nanoparticles at different Sr doped level. A fined LSMO nanoparticle with 50–300 nm, which is detected using scanning electron microscopy, can be obtained by control sol-gel process. The composition analysis results show a comparable stoichiometric ratio. The two resins coating show a different surface morphology, which is more compact in acrylic resin than in the terpineol. Experimental results show that the variation amplitude of coating emittance is 0.45 within the temperature range of 173–370 K. For the acrylic resin coating, the emittance changes from 0.42 at 173 K to 0.85 at 370 K, and it rises from 0.39 at 173 K to 0.83 at 370 K in terpineol resin coating.

Degradation of Thermal Radiative Properties of Variable Emissivity Device Based on Manganese Oxides in Simulated Space Environment

Study of proton-based long-cycle-life all-solid-state electrochromic device

Radiative Thermal Coats for Passive Temperature Management

Radiative Properties of Thermochromic Material with Solar Reflection Films

Temperature-dependent Emissivity Property in La0.7Sr0.3MnO3 Films

A Thermal Radiation Modulation Platform by Emissivity Engineering with Graded Metal-Insulator Transition

Spacecraft smart radiation device with variable emission and low absorption based on phase change material VO 2

Effects of Space Environment Factors on Optical Materials for Space Application

Latest Progress in Variable Emissivity Thermal Control of Micro-Electro-Mechanical-System Devices

PREPARED METHOD AND RADIATIVE PROPERTIES OF A THERMOCHROMIC VARIABLE EMITTANCE MATERIAL

A review on thermal stability and high temperature induced ageing mechanisms of solar absorber coatings

Modeling and Analysis of A Mems-Based Thermal Emissivity Variable Thermal Control Device

The Measured Study of Natural Weathering Performance of Reflective Thermal Insulation Coating in Hot-Summer and Warm-Winter Region

Visible‐to‐MIR broadband modulating electrochromic metal oxides‐based coating for thermal management

Influence of MnO2 on properties of ZrO2-Al 2O3-SiO2 infrared radiation materials

Evaluation and Analysis of Thermal Control Materials under Ground Simulation Test for Space Environment Effects

Ionic Thermal Synthesis and Reversible Heat Storage Performance of Manganese-based Oxides

Experimental Demonstration of Dynamic Thermal Regulation using Vanadium Dioxide Thin Films

Total Hemispherical Emittance of Low Temperature Curing Thermochromic Coatings

Composition and Temperature Dependence of Electronic and Optical Properties in Manganese Doped Tin Dioxide Films on Quartz Substrates Prepared by Pulsed Laser Deposition

Degradation of the Optical Properties of Zinc-Oxide Micropowders and Nanopowders under Proton and Electron Irradiation