Abstract:Two-phase flow with low liquid loads is common in high-pressure natural gas offshore gathering and transmission pipelines. During gas production slowdowns or shutdowns, an accumulation of liquid in the lower sections of subsea pipelines may occur. This phenomenon is observed in jumpers that connect different units in deep-water subsea gas production facilities. The displacement of the accumulated liquid during production ramp-up induces temporal variations in pressure drop across the jumper and forces on its elbows, resulting in flow-induced vibrations (FIV) that pose potential risks to the structural integrity of the jumper. To bridge the gap between laboratory experiments and field conditions, transient 3D numerical simulations were conducted using the OpenFOAM software. These simulations facilitated the development of a mechanistic model to elucidate the factors contributing to increased pressure and forces during the liquid purging process. The study examined the influence of gas pressure level, pipe diameter, initially accumulated liquid amount, liquid properties, and gas mass flow rate on the transient pressure drop and the forces acting on the jumper's elbows. The critical gas production rate required for complete liquid removal of the accumulated liquid was determined, and scaling rules were proposed to predict the effects of gas pressure and pipe diameter on this critical value. The dominant frequencies of pressure and force fluctuations were identified, with low-pressure systems exhibiting frequencies associated with two-phase flow phenomena and high-pressure systems showing frequencies attributed to acoustic waves.

Dynamic responses of a jumper in a subsea production facility under earthquake

Dynamic Analysis of the Umbilical Cable Pull-in Operation Through J-tube under Different Wave Directions

Lifting of Horizontal Subsea Pipeline with Diverse Lifting Points in Waves: Hydrodynamic Analysis

Numerical Simulation on Dynamic Behaviour of Deepwater J-lay Systems

Influences of Pipelay Parameters on Dynamic Behavior of Deepwater J-Lay System

Dynamic Response Analysis of a Subsea Rigid M-Shaped Jumper under Combined Internal and External Flows

Ultimate Strength Analysis of a Jumper in Subsea Production Facility

Flow pattern evolution and flow-induced vibration response in multiphase flow within an M-shaped subsea jumper

Experimental research and numerical study of leakage influence on the internal two-phase flow of subsea jumper

The study of hydrodynamic load on a submerged floating tunnel tube in an ideal fluid layer under the action of earthquake P-wave

Spatial Dynamic Response of Submerged Floating Tunnel under Impact Load

On the Numerical Simulation Methods of Internal Multiphase Flow-induced Vibration in Subsea Rigid Jumper

Analysis of dynamic reliability of offshore jacket platforms subjected to seismic action

Seismic Response of Underwater Site

Response analysis of the nodes of pipe networks under seismic load

Seismic-induced Dynamic Responses in a Poro-Elastic Seabed: Solutions of Different Formulations

Modeling of high-pressure transient gas-liquid flow in M-shaped jumpers of subsea gas production systems

Lateral kinematic response of offshore pipe piles to S‐wave seismic excitation

Experimental research on dynamic responses and hydrodynamic pressures of deep-water bridge piers under seismic and wave actions

Experimental study on the dynamic responses of the end‐anchored floating bridge subjected to joint actions of earthquakes and water waves

Dynamic Response Method of Bridge Piers under Earthquake Excitation Considering Fluid-structure Interaction