Abstract:Severe slugging, which could induce large-amplitude pressure and flow rate fluctuations, is a major and expensive problem in multiphase transportation systems of offshore oil production system. To avoid such problem is a basic requirement for flow assurance management. This study is an experimental and numerical investigation of severe slugging in a relatively long pipeline-riser system. A series of experiments on two-phase, air-water flow in a flexible S-shaped riser were carried out. The experimental system has a 114m long horizontal pipeline connected to a 19m long pipe which is inclined to -2degree from horizontal, followed by a 15.3m high riser operating at atmospheric end pressure. Four types of flow patterns were found and characterized by the pressure fluctuations at the bottom of the riser. A flow patter map for the prediction of severe slugging was developed based on the experimental results. The detailed characteristics of severe slugging such as pressure fluctuations, liquid holdup, under different gas-liquid superficial velocities were provided. A transient model to predict the flow behavior in the pipeline-S-shaped riser system was developed based on an existing model (OLGA). The modified model, which was tested against new experimental results obtained in this study, showed that the four types of flow patterns observed in the experiment were predicted with acceptable discrepancies. The flow pattern map was obtained using present model, as well as the detailed characteristics of severe slugging. in addition, the reasons for the difference between experimental and numerical results were analysed in this article. The motive of the numerical studies was to identify the areas that could not be reproduced by the present model and to give some suggestions for future models.

Hydraulic characteristics of pipeline of vertical riser in jam conditions

Dynamic Analysis of Pipeline Lifting Operations for Different Current Velocities and Wave Heights

Effects of a Long Pipeline on Severe Slugging in an S-shaped Riser

Upward Flow of Large Size Particles–Water Mixtures Through Swaying Pipes

Severe slugging in a flexible S-shaped riser system: Experimental studies and transient simulation

ANALYSIS OF STABILITY FAILURE FOR PIPELINE DURING LONG DISTANCE PIPE JACKING

Numerical Investigation on the Dynamics of Mixture Transport in Flexible Risers During Deep-Sea Mining

Experimental Investigation on Mitigation of Severe Slugging in Pipeline-Riser System by Quasi-Plane Helical Pipe Device

Experimental Study on the Influence of the Riser on the Gas-Liquid Flow in the Horizontal Pipeline of the Offshore Pipeline-Riser System

Experimental investigation and prediction of overall and local flow patterns in pipeline-riser systems

Numerical Investigation on Inclined Hydraulic Transport of Large Particles for Deepsea Mining

Experimental and Numerical Study on Gas-Liquid Flow in Hilly-Terrain Pipeline-Riser Systems

Experimental investigation on vortex-induced vibration characteristics of a segmented free-hanging flexible riser

Experimental and Computational Investigations on Severe Slugging in A Catenary Riser

Numerical Analysis of Coarse Particle Two-Phase Flow in Deep-Sea Mining Vertical Pipe Transport with Forced Vibration

Numerical simulation on transport behavior of gradated coarse particles in deep-sea vertical pipe transportation

Effect of High Pressure on Severe Slugging and Multiphase Flow Pattern Transition in a Long Pipeline-Riser System

Experimental investigation of critical suction velocity of coarse solid particles in hydraulic collecting

Experiments on the Severe Slugging Characteristics in a Composite Pipeline System with Different Riser Heights

Analysis of Flow Characteristics and Influencing Factors of Severe Slugging Flow in an Underwater Pipe-Catenary Riser

EXPERIMENTS ON TWO-PHASE FLOW CHARACTERISTICS IN A CATENARY RISER SYSTEM WITH THE GAS AND LIQUID MIXTURE TRANSPORTATION