Abstract:Severe slugging, which could induce large-amplitude pressure and flow rate fluctuations, is a major and expensive problem in multiphase transportation systems of offshore oil production system. To avoid such problem is a basic requirement for flow assurance management. This study is an experimental and numerical investigation of severe slugging in a relatively long pipeline-riser system. A series of experiments on two-phase, air-water flow in a flexible S-shaped riser were carried out. The experimental system has a 114m long horizontal pipeline connected to a 19m long pipe which is inclined to -2degree from horizontal, followed by a 15.3m high riser operating at atmospheric end pressure. Four types of flow patterns were found and characterized by the pressure fluctuations at the bottom of the riser. A flow patter map for the prediction of severe slugging was developed based on the experimental results. The detailed characteristics of severe slugging such as pressure fluctuations, liquid holdup, under different gas-liquid superficial velocities were provided. A transient model to predict the flow behavior in the pipeline-S-shaped riser system was developed based on an existing model (OLGA). The modified model, which was tested against new experimental results obtained in this study, showed that the four types of flow patterns observed in the experiment were predicted with acceptable discrepancies. The flow pattern map was obtained using present model, as well as the detailed characteristics of severe slugging. in addition, the reasons for the difference between experimental and numerical results were analysed in this article. The motive of the numerical studies was to identify the areas that could not be reproduced by the present model and to give some suggestions for future models.

Experimental investigation and prediction of overall and local flow patterns in pipeline-riser systems

Experimental and Numerical Study on Gas-Liquid Flow in Hilly-Terrain Pipeline-Riser Systems

Forecasting the transition to undesirable gas-liquid two-phase flow patterns in pipeline-riser system: A method based on fast identification of global flow patterns

Experimental Study on the Influence of the Riser on the Gas-Liquid Flow in the Horizontal Pipeline of the Offshore Pipeline-Riser System

Statistical Analysis on the Signals Monitoring Multiphase Flow Patterns in Pipeline-Riser System

Upstream-flow-based Mechanisms for Global Flow Regime Transition of Gas/liquid Two-Phase Flow in Pipeline-Riser Systems

A Comparison of Gas-Liquid Two-Phase Flow Behaviors Between Two Offshore Pipeline-Riser Systems with Different Geometric Parameters: from View of Flow Pattern Identification

Research on Severe Slugging Flow Transition Model in Marine Pipeline-Riser System

Experimental Study on Transient Process of Gas and Liquid Flow Rates in Pipeline-riser System

Severe slugging in a flexible S-shaped riser system: Experimental studies and transient simulation

Experimental Study on Differential Pressure Fluctuations Characteristics of Unsteady Flow Pattern in Pipeline-riser System

A visualization study on characteristics of severe slugging in the S-shaped riser with a kilometer-scale pipeline

Fast Recognition of Global Flow Regime in Pipeline-Riser System by Spatial Correlation of Differential Pressures

Experiments and Predictions for Severe Slugging of Gas-Liquid Two-Phase Flows in a Long-Distance Pipeline-Riser System

Self-adaptive Early Warning of Undesirable Gas-Liquid Flow Pattern in Offshore Oil and Gas Pipeline-Riser System

Effect of High Pressure on Severe Slugging and Multiphase Flow Pattern Transition in a Long Pipeline-Riser System

Identification of flow patterns in long pipeline-riser system based on double-category labeling of samples near the transition boundaries

Intelligent Identification of Two-Phase Flow Patterns in a Long Pipeline-Riser System

Signal optimization for recognition of gas–liquid two-phase flow regimes in a long pipeline-riser system

Effects of Riser Height and Pipeline Length on the Transition Boundary and Frequency of Severe Slugging in Offshore Pipelines

Gas-liquid two-phase flow patterns in a pipeline-riser system with an S-shaped riser