Abstract:Accidental releases of superheated liquids, such as liquefied petroleum or natural gases, are featured by depressurization across the outlet leading to liquid flashing within the upstream container and the downstream jet. In this work, dynamic behaviors of in-tank liquid with phase change throughout depressurized releases and the influence on the primary breakup of flashing jet were studied with an experimental 20 L tank. In-tank parameters (pressure, temperature, and liquid mass) and downstream jet morphology were characterized. A new nondimensional number (ηp), the ratio between the superheat levels of the saturated states corresponding to liquid temperature and pressure, was developed to describe the liquid's thermodynamic state under both release and ambient conditions. A thermodynamics-determined release rate model was established to characterize flow behaviors at the exit. Results showed a strong correlation between the initial ηp0 and key process parameters I (depressurization and release rates): I = aηp0b, where a and b are constants for a particular I. A ηp0-based criterion was derived to characterize in-tank release dynamics and thermodynamics: ηp0 < 0.25 (subcooled), 0.25<ηp0 < 0.4 (transition from subcooled to superheated), and ηp0 > 0.4 (superheated). Mild evaporation and flash evaporation dominated in-tank pressure recovery when ηp0 < 0.25 and ηp0 > 0.25, inhibiting depressurization. The release rate model agreed well with experiments and demonstrated that flashing happens upstream and chokes the induced two-phase flow when ηp0 > 0.25, decreasing the release rate. The evolving upstream conditions changed the breakup regime both in mechanical and thermodynamic aspects. Moreover, the thermodynamic effect increased as the mechanical effect decreased during depressurization.

Experimental Investigation on the Rapid Evaporation of High-Pressure R113 Liquid Due to Sudden Depressurization

Experimental Investigation on Rapid Evaporation of High-Pressure Liquids Due to Depressurization

Transient Heat Transfer Characteristics of Supercritical Fluid During Rapid Depressurization Process

Heat Transfer Characteristics of Evaporation Process of High Pressure Freon R113 Liquids during Depressurization

Rapid Solidification Process of a Water Droplet Due to Depressurization

Dynamics Of Evaporation And Cooling Of A Water Droplet During The Early Stage Of Depressurization

Experimental and Theoretical Investigation on Rapid Evaporation of Ethanol Droplets and Kerosene Droplets During Depressurization

Possibility of Volume Reduction of Blowdown Tank in Fusion Reactor Safety System

Numerical Investigation of the Transient Behavior of A Hot Gas Duct under Rapid Depressurization

Experimental Study on Explosive Boiling Mechanism of Superheated Liquid Containing Ethanol Impurities under Rapid Depressurization

Dynamic Behaviors of In-Tank Subcooled Liquid with Depressurization-Induced Phase Change and the Impact on Primary Breakup of Flashing Jet

Experimental Study on Depressurization of Freon at Supercritical Pressure

Experimental Investigation Evaporation Of Liquid Mixture Droplets During Depressurization And Into Air Stream

Transient Thermodynamic Behaviors of Super-high Temperature Gas-carrying Duct under Rapid Depressurization

THE EFFECTS OF A NON-CONDENSABLE GAS ON PRESSURIZER INSURGE TRANSIENTS UNDER THE HIGH PRESSURE

Experimental study on temporal and spatial distribution of bubbles during initial stage of static flash of pure water

Release Behaviour of a High-Pressure Vapor Vessel with Condensation: Test and Modeling Study

Thermal Nonequilibrium and Mechanical Forces Induced Breakup and Droplet Formation of Superheated Liquid Jets under Depressurized Release

Evaporation of a Sessile Water Droplet During Depressurization

Experimental Study on Fluid Thermal Stratification During Operation of Thermodynamic Vent

Experimental Study of the Processes of Gas-Steam Pressurizer Insurge Transients