Abstract:Nanostructured zinc oxide (ZnO) for gas sensing application has been prepared by using normal and oblique angle sputtering deposition techniques under different substrate temperatures. Oblique angle plasma beam deposition is demonstrated effectively growing large-area uniformly aligned and inclined ZnO nanorod arrays on catalyst-free silicon substrate due to a self-shadowing mechanism, whereas normal radio frequency sputtering deposition yields nanoparticles as island growth mode. Furthermore, the density of the nanorod arrays is dependent on the incident angle of ZnO plasma beam. With an increase of the incident flux angle, large inter spacing was induced, resulting in sparser nanorod arrays. The nanorod arrays grown with an incident angle of 70 have an average diameter of similar to 150-300 nm and length of similar to 700-750 nm. The experimental data from characterization of the samples indicates that the obtained samples at different substrate temperatures and incident angles have wurtzite structure with a c-axis orientation.Sensing characterization reveals that the nanorod-based sensor shows higher sensitivity, faster response and recovery time, as well as better reproducibility than that of nanoparticle-based gas sensor to 100 ppm hydrogen and methane at low operating temperature below 150 degrees C due to the porosity and large grain boundaries of the nanorod arrays. It demonstrates that oblique angle of sputtering deposition is a simple, inexpensive synthesis process to get high-porosity nanostructures and as a result, improves the sensing properties of fabricated ZnO sensors, which permits us to obtain sensors with high sensitivity, low operating temperature and stability. (C) 2011 Elsevier B.V. All rights reserved.

Chemical Vapor Deposition Preparation of Nanostructured ZnO Particles and Their Gas-Sensing Properties

Controlled preparation and gas sensitive properties of two-dimensional and cubic structure ZnSnO3

Zn-Doped In2o3 Nanostructures: Preparation, Structure and Gas-Sensing Properties

Preparation and gas-sensitive properties of hollow Zn2SnO4/SnO2 nano-cubes

Gas Sensing Properties of ZnO-SnO2 Nanostructures.

Large-scale synthesis of flowerlike ZnO nanostructure by a simple chemical solution route and its gas-sensing property

UV-light Illumination Room Temperature HCHO Gas-Sensing Mechanism of ZnO with Different Nanostructures

Nanostructures and Sensing Properties of ZnO Prepared Using Normal and Oblique Angle Deposition Techniques

Controllable Preparation and Gas Sensing Performance of Nanosized ZnO with Different Micromorphologies

Abnormal N-P-n Type Conductivity Transition of Hollow ZnO/ZnFe2O4 Nanostructures During Gas Sensing Process: the Role of ZnO-ZnFe2O4 Hetero-Interface

Preparation and Gas Sensing Properties of ZnO/SnO2 Hierarchical Nanostructures

Synthesis of ZnO Hierarchical Structures and Their Gas Sensing Properties

Defect-Controlled Gas Sensing Property of Nanostructured ZnO Films

Hierarchical core/shell ZnO/NiO nanoheterojunctions synthesized by ultrasonic spray pyrolysis and their gas-sensing performance

Synthesis and H2 Gas-Sensing Property of ZnO Nanobelts

Hydrothermal Synthesis and Growth Mechanisms of Different ZnO Nanostructures and Their Gas-Sensing Properties

Hollow cylinder ZnO/SnO2 nanostructures synthesized by ultrasonic spray pyrolysis and their gas-sensing performance

Enhanced Formaldehyde Sensing Properties of SnO2 Nanorods Coupled with Zn2SnO4

Hierarchically Structure SnO<sub>2</sub>/ZnO Nanocomposites: Preparation, Growth Mechanism and Gas Sensing Property

Synthesis and Gas-Sensing Properties of ZnO@NiCo2O4 Core@shell Nanofibers

Study on Photoelectric Gas-Sensing Property and Photogenerated Carrier Behavior of Ag–ZnO at the Room Temperature