Abstract:The granular motion of binary-size mixture in a three-dimensional rotating drum operating in the rolling regime is numerically tracked via the discrete element method (DEM), with a focus on the axial dispersion behavior of the different particle types in response to the inherent size-segregation. Accordingly, the evolution with time, the frequency distribution and the space-time profiles of the axial dispersion coefficients are evaluated. The results demonstrate that (i) the fast radial segregation gives rise to the sharp increase and decrease of the axial dispersion coefficients of respectively the large and small particles in both the active and passive regions; (ii) the axial dispersion coefficients in the active region is an order-of-magnitude higher than that in the passive region; (iii) after the radial segregation, the frequency distributions of the axial dispersion coefficients of the large particles, the small particles and all the particles are normal distributions; (iv) the greatest axial dispersion coefficients of both particle types are at the upper part of the active region near the bed surface; (v) increasing the rotating speed and particle diameter ratio clearly enhances the axial dispersion intenstity in the active and passive regions; and (vi) axial segregation results in the greatest axial dispersion near the end walls, while most of the rest of the drum exhibit equally low axial dispersion. The results obtained here contribute towards understanding the dynamical response of the axial dispersion of different particle types to the inevitable radial and axial segregation phenomena, and are expected to be valuable for improving operations and advancing theoretical models of such granular systems with constituents of different sizes.

Numerical Study of Mixing and Thermal Conduction of Granular Particles in Rotating Tumblers

Studying on the Upper Limit of the Coarse-Grained DEM Model for Simulating Mixing Processes in a Rolling Drum with Complex Wall Boundary

DEM simulation and analysis of particle mixing and heat conduction in a rotating drum

DEM Simulation of Heat Transfer in Granular Materials

A Macroscopic and Microscopic Study of Particle Mixing in a Rotating Tumbler

Numerical Study of Mixing of Binary-Sized Particles in Rotating Tumblers on the Effects of End-Walls and Size Ratios

Numerical investigation of mixing and heat transfer of granular material in a ribbon reactor: effect of impeller speed and filling rate

An Experimentally Validated Coarse-Grain DEM Study of Monodisperse Granular Mixing

DEM investigation of the axial dispersion behavior of a binary mixture in the rotating drum

DEM Study of the Size-Induced Segregation Dynamics of a Ternary-Size Granular Mixture in the Rolling-Regime Rotating Drum

Three-dimensional axial dispersion dynamics of granular flow in the rolling-regime rotating drum

Discrete Element Method Simulation on the Immigration of Granular Matter in a Vertically Vibrating U-Tube

Particle Mixing Study in Rotating Wavy Wall Tumblers by Discrete Element Method Simulation

Numerical Study of Heat Conduction of Granular Particles in Rotating Wavy Drums

Numerical Study of the Distribution Characteristics on Particle Mixing and Thermal Conduction in Wavy Drum

Application in granular flows

Numerical Study on Particle Mixing in a Double-Screw Conical Mixer

Influence of rotating velocity on particle mixing characteristics in a three-dimensional tumbler

Numerical investigation of the particle flow behaviors in a fluidized-bed drum by CFD-DEM

Experimental investigation of heat generation during the mixing of granular materials using an overhead stirrer

Modelling of the Flow of Ellipsoidal Particles in a Horizontal Rotating Drum Based on DEM Simulation