Abstract:The growth kinetics of colloidal Al(III)-containing particles (diameter<1000 nm), nucleated in optically clear, supersaturated sodium aluminate solutions as a precursor to Al(OH)3 crystals, has been studied using dynamic light scattering. Two series of solutions were examined at 22 °C to determine the influence of Al(III) supersaturation and NaOH concentration on the initial particle growth behavior. One solution series consisted of solutions with constant Al(III) absolute supersaturation (ΔC) of 1.48 M and [NaOH] range 1.83–4.00 M ([NaOH]/[Al(III)]=1.13–2.15) and Al(III) relative supersaturation (σ)=3.86–10.36. The other solution series had a constant σ of 7.55 and [NaOH] range of 1.50–4.27 M ([NaOH]/[Al(III)]=1.18–1.54) and ΔC=0.86–3.19. The correlation between the initial particle growth rates and supersaturation (ΔC or σ) revealed marked anomalies over the entire supersaturation range studied. The growth rate remained substantially constant in the ΔC range 0.86–2.55 M (for the constant σ solution series), before increasing sharply upon a further increase of ΔC beyond 2.55 M. The variation of the growth rate with σ in the range 3.86–9.00 (for the constant ΔC solution series) was remarkably weak, contrary to expectation. At higher σ (>9.00), however, a marked increase in growth rate with increasing σ was displayed. At constant ΔC or σ, the growth rate showed a strong variation with NaOH concentration, indicating that Na+ and OH− species play a pivotal role in the Al(OH) precursor particles (nuclei) growth process. Furthermore, the kinetics of growth displayed by these nanosized particles are an order of magnitude slower than those observed for macroscopic gibbsite (γ-Al(OH)3) crystals at similar supersaturations and temperature. The difference may be rationalized in terms of particle size and Al(OH)3 dimorphic phase dependent solubility effects. An empirically adequate growth kinetics modeling was achieved when the growth rates were correlated with the Al(III) supersaturation (ΔC or σ) and the excess (free) NaOH concentration, rather than the former alone, as is commonly the case. A critical [NaOH]/[Al(III)] molar ratio of 1.27–1.35, below which the particle growth rate increased markedly and above which the rate was significantly reduced, was observed. This behavior is believed to be linked to solution speciation change that occurs at certain Al(III) and NaOH compositions.

Effect of Supersaturation on Competitive Nucleation of CaSO4 Phases in a Concentrated CaCl2 Solution

Effect of Mg2+ Ions on the Nucleation Kinetics of Calcium Sulfate in Concentrated Calcium Chloride Solutions

Calcium Sulfate Polymorph Evolution Dominated by Competitive Nucleation in Gypsum Metastable Zone

Insight into Metastable Lifetime of Α‐calcium Sulfate Hemihydrate in CaCl2 Solution

Solubility and Phase Transitions of Calcium Sulfate in KCl Solutions Between 85 and 100 °C

Influences of Citric Acid on the Metastability of Α-Calcium Sulfate Hemihydrate in CaCl2 Solution

Structures and dynamic hydration of CaSO4 clusters in supersaturated solutions: A molecular dynamics simulation study

Studies on the Nucleation of Supersaturated Ammonium Tetramolybdate Solution

Effect of Impurities on the Solubility, Metastable Zone Width, and Nucleation Kinetics of Borax Decahydrate

The influence of Al(III) supersaturation and NaOH concentration on the rate of crystallization of Al(OH)3 precursor particles from sodium aluminate solutions.

Effects of Na, Ca, Mg, and Al Chloride Salts on Dissolution and Phase Stability of Calcium Sulfate Dihydrate in Aqueous Solutions at 278.15 K to 308.15 K

Effect Of Potassium Sodium Tartrate And Sodium Citrate On The Preparation Of Alpha-Calcium Sulfate Hemihydrate From Flue Gas Desulfurization Gypsum In A Concentrated Electrolyte Solution

Saltation phenomenon of CaSO4·2H2O solubility in (NH4)2SO4-H2O system

Effect of ultrasound on the heterogeneous nucleation of BaSO4 during reactive crystallization

Insights Into Water-Mediated Ion Clustering In Aqueous Caso4 Solutions: Pre-Nucleation Cluster Characteristics Studied By Ab Initio Calculations And Molecular Dynamics Simulations

Solution-Mediated Transformation Kinetics Of Calcium Sulfate Dihydrate To Alpha-Calcium Sulfate Hemihydrate In Cacl2 Solutions At Elevated Temperature

Control of crystal morphology through supersaturation ratio and mixing conditions

Influence of Temperature and Solution Composition on the Formation of Calcium Sulfates

Molecular Dynamics Study on the Nucleation Characteristics of Mixed Na2SO4/K2SO4 Solution in Supercritical Water

Insight into the Roles of Two Typical Ion Clusters and Their Second Hydration Shells: Implication for the Nucleation Mechanism in MgSO4 Aqueous Solution

Crystal Phase Selection in Precipitation Process of Calcium Oxalate with Different Supersaturation Degree