Abstract:The calculation reliability of pressure drop and gas–solid drag force in horizontal dilute phase pneumatic conveying strongly depends on the accuracy of gas–solid velocity correlation. However, there are limited studies on the solid velocity in horizontal dilute phase pneumatic conveying and it is important to further validate suitability of existing correlation of gas–solid velocity, especially for fine particles (such as pulverized coal). Consequently, in this paper, a negative pressure pneumatic conveying test rig is set up and two kinds of powders with different sizes are adopted. Optical fiber probe (OFP) was used to measure the volumetric solid concentration and particle velocity. The volumetric solid concentration was also calculated by using the measured particle velocity. The results show that the solid concentrations obtained by the two methods have good agreement, and discrepancy is within ±20%. It was found the particle velocities are different in the upper and lower part of the cross-section in the horizontal pipe. However, the difference is generally no more than 2m/s. The velocity difference will decrease with the increasing gas velocity, and increases with the solid mass flow rate. In the experimental condition of 0.06mm<ds<0.35mm, 1400kg/m3<ρs<2600kg/m3, the implicit correlation based on Yang's Unified Theory gives the best prediction of particle velocity among existing studies but still with noticeable discrepancy with the comparison of the present experimental data. By modifying the solid friction factor, an improved correlation of the particle velocity was obtained, which agrees better with the experimental data given in the present and literature studies.

Experimental study on dense phase pneumatic conveying of pulverized blending of biomass and coal at high pressure

Multi-Scale Analysis of Acoustic Emission Signals in Dense-Phase Pneumatic Conveying of Pulverized Coal at High Pressure

Research on Resistance Properties for Dense Phase Pneumatic Conveying of Pulverized Coal in Vertical Pipe at Different Pressures

Conveying mechanisms of dense-phase pneumatic conveying of pulverized lignite in horizontal pipe under high pressure

Study on the Continuous Transportation of Biomass under High Pressure

Experimental Study of Dense-Phase Pneumatic Conveying of Pulverized Coal at Elevated Pressures

Effect of Moisture Content on Flow Behavior and Resistance Characteristics of Dense-Phase Pneumatic Conveying

Experimental study on the solid velocity in horizontal dilute phase pneumatic conveying of fine powders

Experimental Study On Pressure Drops For Dilute Phase Pneumatic Conveying In Pipe Bends Of Coal Pulverization System Of Boiler

Dense-phase pneumatic conveying of ash in the co-generation technology of CFB combustion combined with coal pyrolysis

Research on the Pneumatic Conveying Characteristics of Fly Ash in the Power Station

Quantitative Characterization of Pulverized Coal and Biomass–coal Blends in Pneumatic Conveying Pipelines Using Electrostatic Sensor Arrays and Data Fusion Techniques

Numerical simulation of dense-phase pneumatic conveying in vertical pipe for gasifier

Analysis and possible solutions for pulverized coal conveying problems of dry feed gasifiers

Flow Patterns of Pneumatic Conveying of Pulverized Coal in Horizontal Pipes for Pressurized Conditions

Fluidized dense phase pneumatic conveying: a review

Experimental Investigation On The Influence Of Air Velocity On The Particle Dispersion Behavior Of Rice Husk In A Fuel-Rich/Lean

Research on the Pressure Dropin Horizontal Pneumatic Conveying for Large Coal Particles

Pressure Drop Characteristics of Vertical Dilute-phase Gas Conveying

Research on Pneumatic Transmit Characteristic of High Density Powdered Solid

Analysis of dense phase pneumatic conveying of fly ash using CFD including particle size distribution