Abstract:The calculation reliability of pressure drop and gas–solid drag force in horizontal dilute phase pneumatic conveying strongly depends on the accuracy of gas–solid velocity correlation. However, there are limited studies on the solid velocity in horizontal dilute phase pneumatic conveying and it is important to further validate suitability of existing correlation of gas–solid velocity, especially for fine particles (such as pulverized coal). Consequently, in this paper, a negative pressure pneumatic conveying test rig is set up and two kinds of powders with different sizes are adopted. Optical fiber probe (OFP) was used to measure the volumetric solid concentration and particle velocity. The volumetric solid concentration was also calculated by using the measured particle velocity. The results show that the solid concentrations obtained by the two methods have good agreement, and discrepancy is within ±20%. It was found the particle velocities are different in the upper and lower part of the cross-section in the horizontal pipe. However, the difference is generally no more than 2m/s. The velocity difference will decrease with the increasing gas velocity, and increases with the solid mass flow rate. In the experimental condition of 0.06mm<ds<0.35mm, 1400kg/m3<ρs<2600kg/m3, the implicit correlation based on Yang's Unified Theory gives the best prediction of particle velocity among existing studies but still with noticeable discrepancy with the comparison of the present experimental data. By modifying the solid friction factor, an improved correlation of the particle velocity was obtained, which agrees better with the experimental data given in the present and literature studies.

Conveying mechanisms of dense-phase pneumatic conveying of pulverized lignite in horizontal pipe under high pressure

Effect of Moisture Content on Flow Behavior and Resistance Characteristics of Dense-Phase Pneumatic Conveying

Research Progress of Granular Flow and Fluidization Behavior of Coarse Cohesive Particles

Multi-Scale Analysis of Acoustic Emission Signals in Dense-Phase Pneumatic Conveying of Pulverized Coal at High Pressure

Research on Resistance Properties for Dense Phase Pneumatic Conveying of Pulverized Coal in Vertical Pipe at Different Pressures

Numerical simulation of dense-phase pneumatic conveying in vertical pipe for gasifier

Analysis and possible solutions for pulverized coal conveying problems of dry feed gasifiers

Flow Patterns of Pneumatic Conveying of Pulverized Coal in Horizontal Pipes for Pressurized Conditions

Triboelectrification characteristics of associated minerals in coal

Research on the Pneumatic Conveying Characteristics of Fly Ash in the Power Station

Dense-phase pneumatic conveying of ash in the co-generation technology of CFB combustion combined with coal pyrolysis

Experimental Study of Dense-Phase Pneumatic Conveying of Pulverized Coal at Elevated Pressures

Experimental study on the solid velocity in horizontal dilute phase pneumatic conveying of fine powders

Fluidized dense phase pneumatic conveying: a review

Numerical study of slug characteristics for coarse particle dense phase pneumatic conveying

Research on the Pressure Dropin Horizontal Pneumatic Conveying for Large Coal Particles

Analysis of gas-solid flow characteristics in intricate pipelines

Solid friction coefficient in a horizontal straight pipe of pneumatic conveying

STUDY ON KEY TECHNOLOGIES AFFECTING THE CONVEYING AND COMBUSTION PROPERTIES OF HIGH DENSITY PULVERIZED COAL

Research on Pneumatic Transmit Characteristic of High Density Powdered Solid

Quantitative Characterization of Pulverized Coal and Biomass–coal Blends in Pneumatic Conveying Pipelines Using Electrostatic Sensor Arrays and Data Fusion Techniques