Abstract:Pressurized oxy-coal combustion has received wide attention recently due to its potential of high efficiency and low cost in CO2 capture. However, there is still a significant knowledge gap on the effects of pressure on the oxycoal and oxy-char combustion behaviors. In this study, oxy-char combustion experiments were carried out in a pressurized fluidized bed combustor, and the effects of pressure and oxygen concentration on the burnout time, reactivity and temperature of the char particles were investigated. The experimental results showed that the burnout time of the char particles decreased significantly with an increase in pressure from 0.1 MPa to 0.5 MPa. Besides, an increase in either the combustion pressure (within the range of 0.1 - 0.5 MPa) or the oxygen concentration (within the range of 10 - 30% O-2 in CO2) led to increases in the reactivity and temperature of the char particles, while the promotional effects of the pressure increase were weaker at the higher pressures. In order to better interpret the experimental results, a combustion model considering reaction kinetics, mass and heat transfer, and energy balance was developed and validated by the experimental results. The model simulation results showed that an increase in pressure would reduce the burnout time of char particles only when the combustion was kinetically controlled or combined kinetic-diffusion controlled. Once the combustion became diffusion-controlled, a further increase in pressure would have an insignificant effect on the char burnout time. Although the values of kinetic constants were different when different kinetic models, the global power-law model and Langmuir-Hinshelwood model, were adopted, the simulation results of the burnout time of the char particle under the pressurized fluidized bed combustion conditions were almost the same since the char combustion was mainly diffusion-controlled. The elevated combustion pressure accelerated both the char combustion rate and the char-CO2 gasification rate, while the carbon consumption ratio by gasification increased with pressure. Moreover, the enhanced gasification reaction had a great impact on the particle temperature especially under the higher oxygen concentration combustion conditions.

Char burnout of U.S. and Chinese coals under oxy-combustion conditions

Measurements and Modelling of Oxy-Fuel Coal Combustion

Kinetic study on in-situ and cooling char combustion in a two-step reaction analyzer

Burnout Characteristic of Coal Chars Under Oxyfuel Combustion Conditions

A Kinetic Study on Char Oxidation in Mixtures of O2, CO2 and H2O

Investigating the Combustion Characteristic Temperature of 28 Kinds of Chinese Coal in Oxy-Fuel Conditions

Experimental research on coal/char combustion in O-2/CO2 mixed atmosphere

Study on Combustion Characteristic of Coal-Char in Oxygen-Enriched Environments

Experimental And Numerical Analyses On Ignition And Burnout Characteristic Of Low-Rank Lignite And Semi-Char Blends

Experimental Investigation of the Combustion of Bituminous Coal in Air and O-2/Co2 Mixtures: 1. Particle Imaging of the Combustion of Coal and Char

Kinetic Characteristics of Coal Char Combustion in Oxygen-Enriched Environment

Combustion Interactions of Blended Chars under Oxidation and Gasification Competition in Oxy–Fuel Condition

Experimental Investigation of Pressurized Combustion Characteristics of a Single Coal Particle in O-2/N-2 and O-2/CO2 Environments

Research on Oxy-Fuel Combustion Characteristics of Two Typical Chinese Coals

Experimental and kinetics analyses of a typical Zhundong coal reaction in O2/CO2/H2O atmosphere

Experimental study of a single char particle combustion characteristics in a fluidized bed under O2/H2O condition

Dynamic and kinetic studies on the oxy-coal combustion using multi-parameter high-speed diagnostics

Experimental Study And Analysis Of Coal Combustion On A Cfb Test-Facility In O-2/Co2 And O-2/N-2 Mixtures

Pyrolysis and Combustion Characteristics of Coals in Oxyfuel Combustion

Experimental Study and Modeling of Oxy-Char Combustion in a Pressurized Fluidized Bed Combustor

Experimental Study on Ignition and Combustion Characteristics of Pyrolyzed Char in an O-2-Enriched Atmosphere with Multiple Optical Diagnostic Techniques